HOW TO USE THIS MANUALHOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
CONTENTS OF TROUBLESHOOTING DIAGNOSIS FUNCTION HOW TO USE THE INSPECTION PROCEDURES CONNECTOR MEASUREMENT SERVICE POINTS CONNECTOR INSPECTION SERVICE POINTS INSPECTION SERVICE POINTS FOR A BLOWN FUSE HOW TO COPE WITH INTERMITTENT MALFUNCTIONS
HOW TO TREAT PAST TROUBLE VEHICLE IDENTIFICATIONGENERAL DATA AND SPECIFICATIONSPRECAUTIONS BEFORE SERVICE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND SEAT BELT PRE-TENSIONER CAUTIONS FOR AIR CONDITIONER STARITING VEHICLES WITH AUTOMATED MANUAL TRANSMISSION IN ORDER TO PREVENT VEHICLES FROM FIRE MULTI USE TESTER (M.U.T.-III) SUB ASSEMBLY HOW TO PERFORM VARIANT CODING SERVICING ELECTRICAL SYSTEM PRE-INSPECTION CONDITION ENGINE OILS FORM-IN-PLACE GASKET (FIPG) LEARNING PROCEDURE FOR IDLING IN MPI ENGINE SERVICE FOR VEHICLE WITH AUTO STOP & GO (AS&G) SYSTEM<Vehicles with AS&G system> LEARNING PROCEDURE FOR NEUTRAL POSITION<Vehicles with AS&G system> FORCED LEARNING OF ESTIMATED ETHANOL CONCENTRATION<FFV> APPLICATION OF ANTI-CORROSION AGENTS AND UNDERCOATS BOLTS AND NUTS WITH STABILIZER FOR COEFFICIENT OF FRICTION PRECAUTIONS FOR INSTALLATION OF ON-VEHICLE RADIO TRANSMISSION EQUIPMENT VEHICLE WASHING SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SRS SERVICE PRECAUTIONSSUPPORT LOCATIONS FOR LIFTING AND JACKING STANDARD PART/TIGHTENING-TORQUE TABLEHOW TO READ WIRING DIAGRAMS GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS AND ADHESIVES SPECIAL TOOLSON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECKCRANKSHAFT PULLEYCAMSHAFTOIL PANCRANKSHAFT OIL SEALCYLINDER HEAD GASKET CYLINDER HEAD GASKET REMOVAL AND INSTALLATION<134> CYLINDER HEAD GASKET REMOVAL AND INSTALLATION<3A9>TIMING CHAINENGINE ASSEMBLY GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS AND ADHESIVES SPECIAL TOOLSON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECKCRANKSHAFT PULLEYCAMSHAFTOIL PANCRANKSHAFT OIL SEALENGINE ASSEMBLY GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS AND ADHESIVES SPECIAL TOOLSON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECK LASH ADJUSTER CHECKCRANKSHAFT PULLEYCAMSHAFT AND VALVE STEM SEALOIL PANCRANKSHAFT OIL SEALCYLINDER HEAD GASKETTIMING BELTENGINE ASSEMBLY GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMTIMING BELTFUEL AND EMISSION PARTSWATER PUMP AND WATER HOSEINLET MANIFOLDEXHAUST MANIFOLDROCKER ARMS AND CAMSHAFTCYLINDER HEAD AND VALVESOIL PAN AND OIL PUMPPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATIONS LUBRICANTS SEALANTS OR ADHESIVES SPECIAL TOOLS<3A9, 4A9>ON-VEHICLE SERVICE ENGINE OIL CHECK ENGINE OIL CHANGE<134, 135> ENGINE OIL CHANGE<3A9, 4A9> ENGINE OIL CHANGE<4G1> ENGINE OIL FILTER REPLACEMENT OIL FILTER STUD REPLACEMENT<Except for 4G1> OIL PRESSURE CHECKENGINE OIL COOLER<4G1> GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0105 MANIFOLD ABSOLUTE PRESSURE SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT<134> CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT<3A9> CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT<134> CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT<3A9> CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0140 OXYGEN SENSOR (REAR) CIRCUIT NO ACTIVITY DETECTED<3A9> CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT<134> CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT<3A9> CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT<134> CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT<3A9> CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0515 BATTERY TEMPERATURE SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0555 BRAKE VACUUM SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P0817 STARTER CUT RELAY SYSTEM<Vehicles with AS&G system> CODE NO. P0820 NEUTRAL POSITION SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0830 CLUTCH SWITCH (A) SYSTEM<Vehicles with AS&G system> CODE NO. P0833 CLUTCH SWITCH (B) SYSTEM<Vehicles with AS&G system> CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1608 BATTERY CURRENT SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1961 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P1962 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P1963 TRUSTFUL CHECK MANIFOLD ABSOLUTE PRESSURE SENSOR CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1966 MANIFOLD ABSOLUTE PRESSURE SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1977 COMMUNICATION ERROR CODE NO. P1978 THROTTLE VALVE CONTROL SERVO MALFUNCTION CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM<134> CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM<3A9> CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (NO INITIAL COMBUSTION)<Vehicles without AS&G system> STARTING IMPOSSIBLE (NO INITIAL COMBUSTION)<Vehicles with AS&G system> STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT) THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING. BATTERY RUN DOWN OVERHEATING POOR A/C PERFORMANCE AS&G OFF INDICATOR LAMP OR AS&G INDICATOR LAMP NOT LIT RIGHT AFTER IGNITION SWITCH TURNED ON<Vehicles with AS&G system> ALTHOUGH AUTO STOP & GO (AS&G) OFF SWITCH PRESSED, AS&G OFF INDICATOR LAMP NOT LIT<Vehicles with AS&G system> ALTHOUGH AUTO STOP & GO (AS&G) OFF SWITCH NOT PRESSED, AS&G OFF INDICATOR LAMP LIT<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO STOP NOT CARRIED OUT)<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO START NOT CARRIED OUT)<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO START CARRIED OUT UNDER CONDITION THAT CLUTCH PEDAL NOT OPERATED)<Vehicles with AS&G system> HOOD BUZZER SWITCH CIRCUIT ABNORMAL<Vehicles with AS&G system> ENIGINE-ECU <M/T> OR ENGINE-A/T-ECU <A/T> POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM. FUEL PUMP SYSTEM A/C COMPRESSOR RELAY SYSTEM IGNITION CIRCUIT SYSTEM<134> IGNITION CIRCUIT SYSTEM<3A9> OIL PRESSURE SWITCH SYSTEM CLUTCH SWITCH (B) SYSTEM<Vehicles with AS&G system> DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECK AUTO STOP & GO (AS&G) OFF SWITCH CHECK<Vehicles with AS&G system>INJECTORTHROTTLE BODY ASSEMBLY THROTTLE BODY ASSEMBLY REMOVAL AND INSTALLATION<134> THROTTLE BODY ASSEMBLY REMOVAL AND INSTALLATION<3A9>ENGINE-ECU GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0011 MITSUBISHI INNOVATIVE VALVE TIMING ELECTRONIC CONTROL (MIVEC) SYSTEM CODE NO. P0105 MANIFOLD ABSOLUTE PRESSURE SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT<135> CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT<4A9> CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT<135> CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT<4A9> CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0140 OXYGEN SENSOR (REAR) CIRCUIT NO ACTIVITY DETECTED<4A9> CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM<Except FFV> CODE NO. P0170 ABNORMAL FUEL SYSTEM<FFV> CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0204 NO.4 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT<135> CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT<4A9> CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT<135> CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT<4A9> CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED<Except FFV> CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED<FFV> CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0460 FUEL LEVEL SENSOR SYSTEM<FFV> CODE NO. P0461 FUEL LEVEL SENSOR RANGE/PERFORMANCE PROBLEM<FFV> CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0515 BATTERY TEMPERATURE SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0555 BRAKE VACUUM SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU OR ENGINE-A/T-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P0817 STARTER CUT RELAY SYSTEM<Vehicles with AS&G system> CODE NO. P0820 NEUTRAL POSITION SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P0830 CLUTCH SWITCH (A) SYSTEM<Vehicles with AS&G system> CODE NO. P0833 CLUTCH SWITCH (B) SYSTEM<Vehicles with AS&G system> CODE NO. P1021 OIL CONTROL VALVE CIRCUIT<135> CODE NO. P1021 OIL CONTROL VALVE CIRCUIT<4A9> CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1608 BATTERY CURRENT SENSOR SYSTEM<Vehicles with AS&G system> CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1961 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P1962 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P1963 TRUSTFUL CHECK MANIFOLD ABSOLUTE PRESSURE SENSOR CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1966 MANIFOLD ABSOLUTE PRESSURE SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1968 TRUSTFUL CHECK AUTOMATED MANUAL TRANSMISSION <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1975 CYCLIC RAM TEST (GEAR) <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1976 CYCLIC RAM TEST (CLUTCH) <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1977 COMMUNICATION ERROR CODE NO. P1978 THROTTLE VALVE CONTROL SERVO MALFUNCTION CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM<135> CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM<4A9> CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU OR ENGINE-A-M/T-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (NO INITIAL COMBUSTION)<Vehicles without AS&G system> STARTING IMPOSSIBLE (NO INITIAL COMBUSTION)<Vehicles with AS&G system> STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START)<Except FFV> STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START)<FFV> UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT)<Except FFV> UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT)<FFV> THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT)<Except FFV> THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT)<FFV> THE ENGINE STALLS WHEN DECELERATING.<Except FFV> THE ENGINE STALLS WHEN DECELERATING.<FFV> ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE<Except FFV> HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE<FFV> THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING.<Except FFV> THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING.<FFV> THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING.<Except FFV> ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING.<FFV> BATTERY RUN DOWN OVERHEATING POOR A/C PERFORMANCE AS&G OFF INDICATOR LAMP OR AS&G INDICATOR LAMP NOT LIT RIGHT AFTER IGNITION SWITCH TURNED ON<Vehicles with AS&G system> ALTHOUGH AUTO STOP & GO (AS&G) OFF SWITCH PRESSED, AS&G OFF INDICATOR LAMP NOT LIT<Vehicles with AS&G system> ALTHOUGH AUTO STOP & GO (AS&G) OFF SWITCH NOT PRESSED, AS&G OFF INDICATOR LAMP LIT<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO STOP NOT CARRIED OUT)<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO START NOT CARRIED OUT)<Vehicles with AS&G system> AUTO STOP & GO (AS&G) SYSTEM ABNORMAL (AUTO START CARRIED OUT UNDER CONDITION THAT CLUTCH PEDAL NOT OPERATED)<Vehicles with AS&G system> HOOD BUZZER SWITCH CIRCUIT ABNORMAL<Vehicles with AS&G system> ENIGINE-ECU <M/T> OR ENGINE-A/T-ECU <A/T> POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM. FUEL PUMP SYSTEM A/C COMPRESSOR RELAY SYSTEM IGNITION CIRCUIT SYSTEM<135> IGNITION CIRCUIT SYSTEM<4A9> OIL PRESSURE SWITCH SYSTEM CLUTCH SWITCH (B) SYSTEM<Vehicles with AS&G system> DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECK OIL CONTROL VALVE CHECK AUTO STOP & GO (AS&G) OFF SWITCH CHECK<Vehicles with AS&G system>INJECTORTHROTTLE BODY ASSEMBLY THROTTLE BODY ASSEMBLY REMOVAL AND INSTALLATION<135> THROTTLE BODY ASSEMBLY REMOVAL AND INSTALLATION<4A9>ENGINE-ECU, ENGINE-A-M/T-ECU GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0011 MITSUBISHI INNOVATIVE VALVE TIMING ELECTRONIC CONTROL (MIVEC) SYSTEM CODE NO. P0090 FUEL PRESSURE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0100 AIR FLOW SENSOR SYSTEM CODE NO. P0105 BAROMETRIC PRESSURE SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0140 OXYGEN SENSOR (REAR) CIRCUIT NO ACTIVITY DETECTED CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0204 NO.4 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0243 WASTE GATE SOLENOID VALVE SYSTEM CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1021 OIL CONTROL VALVE CIRCUIT CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1961 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P1962 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P1963 TRUSTFUL CHECK AIR FLOW SENSOR CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1977 COMMUNICATION ERROR CODE NO. P1978 THROTTLE VALVE CONTROL SERVO MALFUNCTION CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (STARTER INOPERATIVE) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT) THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING. BATTERY RUN DOWN OVERHEATING POOR A/C PERFORMANCE ENGINE-ECU POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM FUEL PUMP SYSTEM A/C COMPRESSOR RELAY SYSTEM IGNITION CIRCUIT SYSTEM OIL PRESSURE SWITCH SYSTEM CLUTCH PEDAL POSITION SWITCH SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECK OIL CONTROL VALVE CHECK FUEL PRESSURE CONTROL SOLENOID VALVE CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU14 -ENGINE COOLING
GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S)<4G1> SPECIAL TOOL(S)TROUBLESHOOTINGON-VEHICLE SERVICE ENGINE COOLANT LEAK CHECK RADIATOR CAP OPENING PRESSURE CHECK ENGINE COOLANT CHANGE<Except for 4G1> ENGINE COOLANT CHANGE<4G1> ENGINE COOLANT CONCENTRATION TEST WATER PUMP COOLANT LEAK CHECK FAN CONTROL RELAY CONTINUITY CHECK RADIATOR FAN MOTOR CHECKTHERMOSTAT THERMOSTAT REMOVAL AND INSTALLATION<Except for 4G1> THERMOSTAT REMOVAL AND INSTALLATION<4G1> THERMOSTAT INSPECTIONWATER PUMPWATER HOSE AND WATER PIPE WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<Except for 4G1> WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<4G1> WATER HOSE AND WATER PIPE INSPECTIONRADIATOR GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE TURBOCHARGER BOOST PRESSURE CHECK<4G1> BOOST PRESSURE CONTROL SYSTEM CHECK<4G1> TURBOCHARGER WASTE GATE ACTUATOR CHECK<4G1> TURBOCHARGER WASTE GATE SOLENOID CHECK<4G1> AIR BY-PASS VALVE CHECK<4G1> INTAKE MANIFOLD VACUUM CHECKAIR CLEANERINTERCOOLER<4G1>INLET MANIFOLD INLET MANIFOLD REMOVAL AND INSTALLATION<134> INLET MANIFOLD REMOVAL AND INSTALLATION<3A9> INLET MANIFOLD REMOVAL AND INSTALLATION<135> INLET MANIFOLD REMOVAL AND INSTALLATION<4A9> INLET MANIFOLD REMOVAL AND INSTALLATION<4G1> INLET MANIFOLD INSPECTIONEXHAUST MANIFOLD<Except for 4G1> EXHAUST MANIFOLD REMOVAL AND INSTALLATION<134, 3A9> EXHAUST MANIFOLD REMOVAL AND INSTALLATION<135, 4A9> EXHAUST MANIFOLD INSPECTIONEXHAUST MANIFOLD AND TURBOCHARGER<4G1> EXHAUST MANIFOLD AND TURBOCHARGER REMOVAL AND INSTALLATION EXHAUST MANIFOLD AND TURBOCHARGER INSPECTIONEXHAUST PIPE AND MAIN MUFFLERCHARGING SYSTEM GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE ALTERNATOR OUTPUT LINE VOLTAGE DROP TEST OUTPUT CURRENT TEST REGULATED VOLTAGE TEST WAVE PATTERN CHECK USING AN OSCILLOSCOPEALTERNATOR ASSEMBLYSTARTING SYSTEMIGNITION SYSTEM
GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S)<Except for 4G1> SPECIAL TOOL(S)ON-VEHICLE SERVICE IGNITION COIL CHECK<134, 135, 4G1> IGNITION COIL CHECK<3A9, 4A9> SPARK PLUG CHECK, CLEANING AND REPLACEMENT<134, 135> SPARK PLUG CHECK, CLEANING AND REPLACEMENT<3A9, 4A9> SPARK PLUG CHECK, CLEANING AND REPLACEMENT<4G1> CAMSHAFT POSITION SENSOR CHECK CRANK ANGLE SENSOR CHECK DETONATION SENSOR CHECKIGNITION COILCAMSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<Except for 4G1> CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<4G1>CRANK ANGLE SENSOR CRANK ANGLE SENSOR REMOVAL AND INSTALLATION<Except for 4G1> CRANK ANGLE SENSOR REMOVAL AND INSTALLATION<4G1>DETONATION SENSORENGINE CONTROLCRUISE CONTROL<135, 4A9, 4G1> GENERAL INFORMATION SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO.15: CRUISE CONTROL SWITCH SYSTEM CODE NO.22: STOP LAMP SWITCH SYSTEM CODE NO.23: ENGINE-ECU AND ITS RELATED COMPONENTS SYMPTOM CHARTSYMPTOM PROCEDURES WHEN BRAKE PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED WHEN CLUTCH PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED<M/T (except AS&G)> WHEN CLUTCH PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED<M/T (AS&G)> WHEN SELECTOR LEVER IS MOVED TO "N" POSITION, CRUISE CONTROL IS NOT CANCELLED<Automated manual transmission> WHEN "CANCEL" SWITCH IS TURNED ON, CRUISE CONTROL IS NOT CANCELLED CRUISE CONTROL CANNOT BE SET. HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED CRUISE CONTROL INDICATOR LIGHT INSIDE COMBINATION METER DOES NOT ILLUMINATE (HOWEVER, CRUISE CONTROL IS NORMAL). DATA LIST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICECRUISE CONTROL SWITCHEMISSION CONTROL <MPI> GENERAL INFORMATION EMISSION CONTROL DEVICE REFERENCE TABLE SERVICE SPECIFICATION(S)VACUUM HOSECRANKCASE EMISSION CONTROL SYSTEM GENERAL INFORMATION (CRANKCASE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (CRANKCASE EMISSION CONTROL SYSTEM) POSITIVE CRANKCASE VENTILATION SYSTEM CHECK POSITIVE CRANKCASE VENTILATION (PCV) VALVE CHECKEVAPORATIVE EMISSION CONTROL SYSTEM GENERAL INFORMATION (EVAPORATIVE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (EVAPORATIVE EMISSION CONTROL SYSTEM) PURGE CONTROL SYSTEM CHECK PURGE PORT VACUUM CHECK<134, 135, 3A9, 4A9> PURGE CONTROL SOLENOID VALVE CHECK CHECK VALVE CHECK<4G1>CANISTERCATALYTIC CONVERTER GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S)ON-VEHICLE SERVICECLUTCH PEDALCLUTCH CONTROL22A-MANUAL TRANSMISSION (FF)
GENERAL INFORMATION LUBRICANTS SPECIAL TOOLSON-VEHICLE SERVICETRANSMISSION CONTROLNEUTRAL POSITION SENSOR<Vehicle with AS&G system>TRANSMISSION ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATIONS SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT TORQUE SPECIFICATION SEALANT(S) AND ADHESIVE(S) LUBRICANTS SPECIAL TOOLSTRANSMISSIONINPUT SHAFTOUTPUT SHAFTDIFFERENTIAL GENERAL INFORMATION LUBRICANT SEALANT AND ADHESIVE SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS FUNCTIONSPECIAL FUNCTION CLUTCH AND GEAR SPECIAL FUNCTION TEACH-IN CLUTCH END POSITION TEACH-IN CLUTCH TOUCH POSITION INITIALIZATION OF CLUTCH PROTECTION DATA INITIALIZATION OF EEPROM START GEARBOX ADAPTION POSITIONIN OF SHIFTDRUMS FOR SENSOR - CHANGE DIAGNOSIS CODE PROCEDURES CHART FOR DIAGNOSIS CODES SYMPTOM CHARTSYMPTOM PROCEDURES Malfunction of Automated Manual Transmission Control Relay System Clutch Actuator System Malfunction Shift Actuator 1, 2 System Malfunction Input Speed Sensor System Malfunction Drum Position Sensor System Malfunction Allshift Lever System Malfunction DATA LIST REFERENCE TABLE CHECK AT ENGINE-A-M/T-ECU TERMINALSON-VEHICLE SERVICE TRANSMISSION OIL LEVEL CHECK TRANSMISSION OIL CHANGE AUTOMATED MANUAL TRANSMISSION CONTROL RELAY CHECKALLSHIFT LEVER ASSEMBLYACTUATORS AND SENSORSTRANSMISSION ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATION SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT TORQUE SPECIFICATION SEALANTS LUBRICANTS SPECIAL TOOLSTRANSMISSIONINPUT SHAFTOUTPUT SHAFTDIFFERENTIAL GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEFRONT AXLE HUB ASSEMBLYDRIVESHAFT ASSEMBLY GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEREAR AXLE HUB ASSEMBLY SERVICE SPECIFICATION(S)TROUBLESHOOTINGON-VEHICLE SERVICE TYRE INFLATION PRESSURE CHECK TYRE WEAR CHECK WHEEL RUNOUT CHECK REMOVING TYREWELD FROM TYRES TREATMENT OF RECOVERY BOTTLE AFTER OLD TYREWELD IS REMOVEDWHEEL AND TYRE GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ENGINE MOUNTING ENGINE MOUNTING REMOVAL AND INSTALLATION<Except for 4G1> ENGINE MOUNTING REMOVAL AND INSTALLATION<4G1>TRANSMISSION MOUNTING TRANSMISSION MOUNTING REMOVAL AND INSTALLATION<Except for 4G1> TRANSMISSION MOUNTING REMOVAL AND INSTALLATION<4G1>ENGINE ROLL STOPPER RODCROSSMEMBER SERVICE SPECIFICATIONS LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE FRONT WHEEL ALIGNMENT CHECK AND ADJUSTMENT LOWER ARM BALL JOINT AXIAL PLAY CHECK LOWER ARM BALL JOINT DUST COVER CHECKSTRUT ASSEMBLY STRUT ASSEMBLY REMOVAL AND INSTALLATION STRUT ASSEMBLY INSPECTION STRUT ASSEMBLY DISASSEMBLY AND REASSEMBLY STRUT ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)LOWER ARM LOWER ARM REMOVAL AND INSTALLATION<Except 4G1> LOWER ARM REMOVAL AND INSTALLATION<4G1> LOWER ARM INSPECTIONSTABILIZER BAR SERVICE SPECIFICATION(S)ON-VEHICLE SERVICESHOCK ABSORBER AND COIL SPRINGTORSION AXLE ARM ASSEMBLY GENERAL INFORMATION SERVICE SPECIFICATIONS LUBRICANTS SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE BRAKE PEDAL CHECK AND ADJUSTMENT BRAKE BOOSTER OPERATING CHECK CHECK VALVE OPERATION CHECK BASIC BRAKE SYSTEM BLEEDING BRAKE FLUID LEVEL SENSOR CHECK BRAKE PAD CHECK BRAKE PAD REPLACEMENT BRAKE DISC CHECK BRAKE LINING THICKNESS CHECK BRAKE DRUM INSIDE DIAMETER CHECK BRAKE LINING AND BRAKE DRUM CONTACT CHECK BRAKE DRAG FORCE CHECKBRAKE PEDALMASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<LHD> MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<RHD>FRONT DISC BRAKE ASSEMBLY FRONT DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY INSPECTIONREAR DISC BRAKE ASSEMBLY REAR DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION REAR DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY INSPECTIONREAR DRUM BRAKE SERVICE SPECIFICATIONS SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS ABS WARNING LAMP INSPECTION DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. C1200 FRONT RIGHT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1205 FRONT LEFT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1210 REAR RIGHT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1215 REAR LEFT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1201 FRONT RIGHT WHEEL SPEED SENSOR CODE NO. C1206 FRONT LEFT WHEEL SPEED SENSOR CODE NO. C1211 REAR RIGHT WHEEL SPEED SENSOR CODE NO. C1216 REAR LEFT WHEEL SPEED SENSOR CODE NO. C1225 ABS SENSOR SYSTEM (OUTPUT SIGNAL MALFUNCTION) CODE NO. C1226, C1236, C1246, C1256 CONTROL SOLENOID VALVE CODE NO. C1266 MOTOR SYSTEM CODE NO. C1276 VALVE RELAY CODE NO. C1340: STOP LAMP SWITCH ERROR CODE NO. C1345 LOW BRAKE FLUID LEVEL CODE NO. C1607 ABS-ECU CODE NO. C1860, C1861 POWER SUPPLY SYSTEM CODE NO. U1073 BUS OFF CODE NO. U1109: ETACS CAN TIME-OUT SYMPTOM CHARTSYMPTOM PROCEDURES THE SCAN TOOL CAN NOT COMMUNICATE WITH THE ABS-ECU. BRAKE WARNING LAMP STAYS ON WITH THE PARKING BRAKE LEVER RELEASED. ABS WARNING LAMP DOES NOT ILLUMINATE WHEN IGNITION SWITCH IS TURNED TO THE ON POSITION (ENGINE STOPPED). BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE IGNITION SWITCH IS TURNED TO ON POSITION (ENGINE STOPPED). ABS WARNING LAMP STAYS ON AFTER THE ENGINE IS STARTED. BRAKES DO NOT FUNCTION NORMALLY. ABS SYSTEM INOPERATIVE ABS OPERATES TOO FREQUENTLY. EMERGENCY BRAKING SIGNAL SYSTEM DOES NOT OPERATE OR OPERATES IMPROPERLY. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICEHYDRAULIC UNITWHEEL SPEED SENSOR SERVICE SPECIFICATION(S) SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS INSPECTION OF ASC INDICATOR LAMP, ASC OFF INDICATOR LAMP, ABS WARNING LAMP, AND BRAKE WARNING LAMP DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. C1200 WHEEL SPEED SENSOR (FR) SYSTEM (OPEN OR SHORT CIRCUIT) CODE NO. C1205 WHEEL SPEED SENSOR (FL) SYSTEM (OPEN OR SHORT CIRCUIT) CODE NO. C1210 WHEEL SPEED SENSOR (RR) SYSTEM (OPEN OR SHORT CIRCUIT) CODE NO. C1215 WHEEL SPEED SENSOR (RL) SYSTEM (OPEN OR SHORT CIRCUIT) CODE NO. C1201 ABS SENSOR SYSTEM CODE NO. C1206 ABS SENSOR SYSTEM CODE NO. C1211 ABS SENSOR SYSTEM CODE NO. C1216 ABS SENSOR SYSTEM CODE NO. C1225 WHEEL SPEED SENSOR SYSTEM MALFUNCTION (ABNORMALITY IN TYRE SIZE) CODE NO. C1226, C1231, C1236, C1241, C1246, C1251, C1256, C1261, C1300, C1305, C1310, C1315 CONTROL SOLENOID VALVE SYSTEM CODE NO. C1266, C1273, C1274 MOTOR SYSTEM CODE NO. C1276 ABNORMALITY IN VALVE RELAY SYSTEM CODE NO. C1340 STOP LAMP SWITCH CODE NO. C1345 BRAKE FLUID LEVEL INSUFFICIENT CODE NO. C1364 BRAKE FLUID PRESSURE SENSOR MALFUNCTION CODE NO. C1366 LATERAL G SENSOR SIGNAL MALFUNCTION CODE NO. C1371 YAW RATE SENSOR SIGNAL MALFUNCTION CODE NO. C1385 YAW RATE SENSOR FUNCTION DECREASE CODE NO. C1387 LATERAL G-SENSOR FUNCTION DECREASE CODE NO. C1388 YAW RATE SENSOR ACTIVE CHECK ERROR CODE NO. C1394 STEERING WHEEL SENSOR NEUTRAL POINT NOT LEARNED CODE NO. C1396 ACTIVE STABILITY SYSTEM CONTROL TEMPORARILY DISABLED (ENGINE TORQUE REQUEST REJECTED) CODE NO. C1505 STEERING WHEEL SENSOR MALFUNCTION CODE NO. C1555 OUTPUT ERROR IN STEERING WHEEL SENSOR CODE NO. C1607 TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU CODE NO. C1621 ABNORMALITY IN G AND YAW RATE SENSOR CODE NO. C1860, C1861 POWER SUPPLY SYSTEM CODE NO. C1862 G AND YAW RATE SENSOR POWER VOLTAGE MALFUNCTION (HIGH VOLTAGE) CODE NO. C1863 G AND YAW RATE SENSOR POWER VOLTAGE MALFUNCTION (LOW VOLTAGE) CODE NO. U1073 BUS OFF CODE NO. U1100 CAN COMMUNICATIONS SYSTEM TIME-OUT ERROR (ENGINE RELATED DATA) CODE NO. U1109: ETACS CAN TIME-OUT CODE NO. U1406 ACCELERATOR PEDAL POSITION SIGNAL ERROR CODE NO. U1426 ENGINE SIGNAL ERROR CODE NO. U1427, U1428, U1429, U1430 ENGINE SIGNAL ERROR SYMPTOM CHARTSYMPTOM PROCEDURES THE SCAN TOOL CAN NOT COMMUNICATE WITH TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU POWER SUPPLY CIRCUIT SYSTEM BRAKE WARNING LAMP STAYS ON WITH THE PARKING BRAKE LEVER RELEASED. ABS WARNING LAMP DOES NOT ILLUMINATE WHEN IGNITION SWITCH IS TURNED TO THE ON POSITION (ENGINE STOPPED). ABS WARNING LAMP STAYS ON AFTER THE ENGINE IS STARTED. BRAKES DO NOT FUNCTION NORMALLY. ABNORMAL ACTIVE STABILITY CONTROL SYSTEM OPERATION TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU POWER SUPPLY CIRCUIT SYSTEM ABS/STABILITY CONTROL/TCL OPERATES TOO FREQUENTLY. ESS INOPERATIVE OR IMPROPER OPERATIVE DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE HYDRAULIC UNIT CHECK REMEDY FOR A DISCHARGED BATTERY G AND YAW RATE SENSOR CALIBRATION STEERING WHEEL SENSOR CALIBRATION BRAKE FLUID PRESSURE SENSOR CALIBRATIONHYDRAULIC UNITWHEEL SPEED SENSORG AND YAW RATE SENSORSTEERING WHEEL SENSOR GENERAL INFORMATION SERVICE SPECIFICATION(S)ON-VEHICLE SERVICEPARKING BRAKE LEVERPARKING BRAKE CABLE GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) AND ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION CHECK OF ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES C1511/C1512 TORQUE SENSOR ABNORMALITY C1513 LARGE DIFFERENCE BETWEEN MAIN TORQUE SENSOR AND SUB TORQUE SENSOR C1514 TORQUE SENSOR POWER SUPPLY ABNORMALITY C1521 VEHICLE SPEED SENSOR INPUT MALFUNCTION C1522 ENGINE SPEED INPUT MALFUNCTION C1531 MOTOR TERMINAL VOLTAGE ABNORMALITY C1532 OVER REAL CURRENT OF MOTOR C1534 UNDER REAL CURRENT OF MOTOR C1541 LOCKING FAIL-SAFE RELAY ON C1542 FAIL-SAFE RELAY STUCK OFF C1607 CONTROL UNIT MALFUNCTION C1860 POWER SUPPLY VOLTAGE ABNORMALITY (HIGH VOLTAGE) C1861 POWER SUPPLY VOLTAGE ABNORMALITY (LOW VOLTAGE) U1073 BUS OFF U1100 ENGINE-RELATED TIME-OUT U1102 ABS-ECU TIME-OUT U1120 ENGINE-RELATED FAIL INFORMATION U1122 ABS-ECU FAIL INFORMATION SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <CAN COMMUNICATION SYSTEM CHECK> M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <ECU POWER SUPPLY CIRCUIT SYSTEM CHECK> ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP ILLUMINATES BUT DIAGNOSIS CODE IS NOT STORED. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE STEERING WHEEL FREE PLAY CHECK STEERING ANGLE CHECK TIE ROD FREE PLAY CHECK TIE ROD END BALL JOINT STARTING TORQUE CHECK STATIONARY STEERING EFFORT CHECK BALL JOINT DUST COVER INSPECTION STEERING COLUMN SHAFT ASSEMBLY SHOCK ABSORBING MECHANISM CHECKSTEERING WHEELSTEERING SHAFTPOWER STEERING GEAR BOX AND LINKAGEELECTRIC POWER STEERING CONTROL UNITHOODON-VEHICLE SERVICE ADJUSTMENT OF CLEARANCE AROUND HOOD ADJUSTMENT OF ALIGNMENT OF HOOD STEPPED PORTION AND HOOD STRIKER ADJUSTMENT OF HOOD HEIGHTHOODFENDERFUEL FILLER LIDSTRUT TOWER BAR<1500 MPI-T/C>PROTECTOR FILM LUBRICANT(S) PROTECTOR FILM REMOVAL AND INSTALLATION<COLT> PROTECTOR FILM REMOVAL AND INSTALLATION<COLT CZ3 (Vehicles without side air dam)>WINDOW GLASS SEALANT(S) OR ADHESIVE(S) LUBRICANT(S) SPECIAL TOOL(S) GENERAL INFORMATIONWINDSHIELDDELTA WINDOW GLASS DELTA WINDOW GLASS REMOVAL AND INSTALLATION<COLT> DELTA WINDOW GLASS REMOVAL AND INSTALLATION<COLT CZ3>QUARTER WINDOW GLASS QUARTER WINDOW GLASS REMOVAL AND INSTALLATION<COLT> QUARTER WINDOW GLASS REMOVAL AND INSTALLATION<COLT CZ3>TAILGATE WINDOW GLASSDOOR SERVICE SPECIFICATION(S)<COLT> SERVICE SPECIFICATION(S)<COLT CZ3> SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHART<CENTRAL DOOR LOCKING SYSTEM>SYMPTOM PROCEDURES<CENTRAL DOOR LOCKING SYSTEM> CENTRAL DOOR LOCKING SYSTEM DOES NOT OPERATE SOME DOORS DO NOT LOCK OR UNLOCK<LH drive vehicles> SOME DOORS DO NOT LOCK OR UNLOCK<RH drive vehicles> SYMPTOM CHART<POWER WINDOWS>SYMPTOM PROCEDURES<POWER WINDOWS> POWER WINDOWS DO NOT WORK AT ALL POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW<LH drive vehicles> POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW<RH drive vehicles> POWER WINDOW SUB SWITCH CANNOT OPERATE PASSENGER''S OR REAR WINDOWS. POWER WINDOW MAIN SWITCH CANNOT OPERATE EITHER OF PASSENGER''S OR REAR POWER WINDOWS POWER WINDOW TIMER FUNCTION DOES NOT WORK NORMALLY WHEN THE GLASS IS RAISED, THEN IT LOWERS AUTOMATICALLY SYMPTOM CHART<DEAD LOCK SYSTEM>SYMPTOM PROCEDURES<DEAD LOCK SYSTEM> DEAD LOCK SYSTEM DOES NOT WORK AT ALL A DOOR DOES NOT WORK EVEN IF THE DEAD LOCK IS OPERATED HAZARD LAMP ANSWERBACK OF DEAD LOCK SYSTEM DOES NOT WORK DEAD LOCK TIMER FUNCTION DOES NOT WORKON-VEHICLE SERVICE<COLT> FRONT AND REAR DOOR FIT ADJUSTMENT<COLT> ADJUSTMENT OF DOOR HEIGHT<COLT> DOOR WINDOW GLASS ADJUSTMENT<COLT> GLASS SLIDING MECHANISM CHECK AND ADJUSTMENT<COLT> POWER WINDOW TIMER FUNCTION CHECK<COLT> POWER WINDOW OPERATING CURRENT CHECK<COLT> POWER WINDOW RELAY CHECK<COLT> POWER WINDOW CHECK<COLT> CENTRAL DOOR LOCKING SYSTEM INSPECTION<COLT> CHECK OF KEY LOCK PREVENTION FUNCTION<COLT> DEAD LOCK SYSTEM INSPECTION<COLT> DEAD LOCK TIMER FUNCTION INSPECTION<COLT> DOOR OUTSIDE HANDLE PLAY CHECK<COLT> DOOR INSIDE HANDLE PLAY ADJUSTMENT<COLT>ON-VEHICLE SERVICE<COLT CZ3> FRONT DOOR FIT ADJUSTMENT<COLT CZ3> ADJUSTMENT OF DOOR HEIGHT<COLT CZ3> DOOR WINDOW GLASS ADJUSTMENT<COLT CZ3> GLASS SLIDING MECHANISM CHECK AND ADJUSTMENT<COLT CZ3> POWER WINDOW TIMER FUNCTION CHECK<COLT CZ3> POWER WINDOW OPERATING CURRENT CHECK<COLT CZ3> POWER WINDOW RELAY CHECK<COLT CZ3> POWER WINDOW CHECK<COLT CZ3> CENTRAL DOOR LOCKING SYSTEM INSPECTION<COLT CZ3> CHECK OF KEY LOCK PREVENTION FUNCTION<COLT CZ3> DEAD LOCK SYSTEM INSPECTION<COLT CZ3> DEAD LOCK TIMER FUNCTION INSPECTION<COLT CZ3> DOOR OUTSIDE HANDLE PLAY CHECK<COLT CZ3> DOOR INSIDE HANDLE PLAY ADJUSTMENT<COLT CZ3>DOOR ASSEMBLY DOOR ASSEMBLY REMOVAL AND INSTALLATION<COLT> DOOR ASSEMBLY REMOVAL AND INSTALLATION<COLT CZ3> DOOR SWITCH CHECKDOOR GLASS AND REGULATOR DOOR GLASS AND REGULATOR REMOVAL AND INSTALLATION<COLT> DOOR GLASS AND REGULATOR REMOVAL AND INSTALLATION<COLT CZ3> DOOR GLASS AND REGULATOR INSPECTION<COLT> DOOR GLASS AND REGULATOR INSPECTION<COLT CZ3>DOOR HANDLE AND LATCH DOOR HANDLE AND LATCH REMOVAL AND INSTALLATION<COLT> DOOR HANDLE AND LATCH REMOVAL AND INSTALLATION<COLT CZ3> DOOR HANDLE AND LATCH INSPECTION<COLT> DOOR HANDLE AND LATCH INSPECTION<COLT CZ3>WINDOW GLASS RUNCHANNEL AND DOOR OPENING WEATHERSTRIPTAILGATE SERVICE SPECIFICATION(S)<COLT> SERVICE SPECIFICATION(S)<COLT CZ3> SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S) TROUBLESHOOTINGON-VEHICLE SERVICE<COLT>ON-VEHICLE SERVICE<COLT CZ3> TAILGATE ADJUSTMENT<COLT CZ3> ADJUSTMENT OF TAILGATE HEIGHT<COLT CZ3> TAILGATE HANDLE PLAY CHECK<COLT CZ3>TAILGATETAILGATE HANDLE AND LATCHKEYLESS ENTRY SYSTEM SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES SYMPTOM CHARTSYMPTOM PROCEDURES KEYLESS ENTRY SYSTEM DOES NOT OPERATE THE DOME LAMP, THE HAZARD WARNING LAMPS AND THE HORN DO NOT OPERATE THROUGH THE ANSWERBACK FUNCTION. AFTER THE DOORS ARE UNLOCKED BY USING THE KEYLESS ENTRY SYSTEM, THE TIMER LOCK FUNCTION DOES NOT WORK. INPUT SIGNAL CHARTINPUT SIGNAL PROCEDURESON-VEHICLE SERVICE KEYLESS ENTRY SYSTEM INSPECTION KEYLESS ENTRY SYSTEM TIMER LOCK FUNCTION INSPECTION METHOD OF REGISTERING A SECRET CODETRANSMITTERLOOSE PANELFRONT BUMPER ASSEMBLYREAR BUMPER ASSEMBLY REAR BUMPER ASSEMBLY REMOVAL AND INSTALLATION<COLT> REAR BUMPER ASSEMBLY REMOVAL AND INSTALLATION<COLT CZ3>MOULDINGSDOOR SASH TAPE SPECIAL TOOL(S) LUBRICANT(S) DOOR SASH TAPE REMOVAL AND INSTALLATION<COLT> DOOR SASH TAPE REMOVAL AND INSTALLATION<COLT CZ3>SIDE AIR DAMTAILGATE SPOILER<1500 MPI-T/C> SEALANT(S) OR ADHESIVE(S) GENERAL INFORMATION TAILGATE SPOILER REMOVAL AND INSTALLATION<COLT> TAILGATE SPOILER REMOVAL AND INSTALLATION<COLT CZ3>WINDSHIELD WIPER AND WASHER SERVICE SPECIFICATION(S) TROUBLESHOOTINGON-VEHICLE SERVICEWINDSHIELD WIPER WINDSHIELD WIPER REMOVAL AND INSTALLATION INSPECTION<LH drive vehicles> INSPECTION<RH drive vehicles>WINDSHIELD WASHERRAIN SENSORREAR WIPER AND WASHERMARKDOOR MIRROR SPECIAL TOOLSINSTRUMENT PANEL ASSEMBLYGLOVE BOXFLOOR CONSOLE ASSEMBLYTRIMSINTERIOR TRIMDOOR TRIMTAILGATE TRIMHEADLININGFRONT SEAT ASSEMBLY SERVICE SPECIFICATION(S) FRONT SEAT ASSEMBLY REMOVAL AND INSTALLATION INSPECTION FRONT SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLYREAR SEAT ASSEMBLYFRONT SEAT BELT FRONT SEAT BELT REMOVAL AND INSTALLATION<COLT> INSPECTION<COLT> FRONT SEAT BELT REMOVAL AND INSTALLATION<COLT CZ3> INSPECTION<COLT CZ3>REAR SEAT BELT GENERAL DESCRIPTION SERVICE PRECAUTIONS SPECIAL TOOL(S) TEST EQUIPMENTSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION SRS WARNING LAMP CHECK DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES DTC B1400 DRIVER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1401 DRIVER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1402 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1403 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1405 SYSTEM INSIDE SRS-ECU DTC B1410 FRONT PASSENGER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1411 FRONT PASSENGER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1412 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1413 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1420 SIDE-AIRBAG SQUIB (RH) SHORT-CIRCUITED DTC B1421 SIDE-AIRBAG SQUIB (RH) OPEN-CIRCUITED DTC B1422 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1423 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1426 G-SENSOR OF SIDE IMPACT SENSOR (RH)FAILURE DTC B1427 SIDE IMPACT SENSOER (RH) VOLTAGE ERROR DTC B1428 SIDE IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1430 SIDE-AIRBAG SQUIB (LH) SHORT-CIRCUITED DTC B1431 SIDE-AIRBAG SQUIB (LH) OPEN-CIRCUITED DTC B1432 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (GROUND SIDE) SHORTED DTC B1433 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1437 SIDE IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1438 SIDE IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1440 CURTAIN AIR BAG SQUIB (RH) SHORT-CIRCUITED DTC B1441 CURTAIN AIR BAG SQUIB (RH) OPEN-CIRCUITED DTC B1442 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1443 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1450 CURTAIN AIR BAG SQUIB (LH) SHORT-CIRCUITED DTC B1451 CURTAIN AIR BAG SQUIB (LH) OPEN-CIRCUITED DTC B1452 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1453 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1460 SEAT BELT PRE-TENSIONER (RH) SQUIB SHORT-CIRCUITED DTC B1461 SEAT BELT PRE-TENSIONER (RH) SQUIB OPEN-CIRCUITED DTC B1462 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1463 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1470 SEAT BELT PRE-TENSIONER (LH) SQUIB SHORT-CIRCUITED DTC B1471 SEAT BELT PRE-TENSIONER (LH) SQUIB OPEN-CIRCUITED DTC B1472 SEAT BELT PRE-TENSIONER (LH) SQUIB (EARTH SIDE) SHORT-CIRCUITED DTC B1473 SEAT BELT PRE-TENSIONER (LH) SQUIB (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1476 POWER SUPPLY VOLTAGE [IG1 (A) VOLTAGE] DROPS ABNORMALLY DTC B1499 IGNITION OF THE AIR BAG COMPLETED DTC B1509 INCORRECT SRS-ECU DTC B1593 SRS-ECU NOISE FAULT DTC U1073 BUS-OFF SYMPTOM CHARTSYMPTOM PROCEDURES THE M.U.T.-III CANNOT COMMUNICATE WITH THE SRS-ECU. POWER SUPPLY CIRCUIT SYSTEM WHEN THE IGNITION SWITCH IS TURNED TO "ON", THE SRS WARNING LAMP DOES NOT ILLUMINATE. AFTER THE IGNITION SWITCH IS TURNED TO "ON", THE SRS WARNING LAMP DOES NOT GO OUT. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE POST-COLLISION DIAGNOSIS INDIVIDUAL COMPONENT SERVICE WARNING/CAUTION LABELSSRS CONTROL UNIT (SRS-ECU)DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING REMOVAL AND INSTALLATION DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING INSPECTIONSIDE AND CURTAIN AIR BAG MODULE(S) SIDE AND CURTAIN AIR BAG MODULE(S) REMOVAL AND INSTALLATION SIDE AND CURTAIN AIR BAG MODULE(S) INSPECTIONSIDE IMPACT SENSORSEAT BELTS WITH PRE-TENSIONERPASSENGER''S AIR BAG CUT OFF SWITCH PASSENGER AIR BAG CUT OFF SWITCH REMOVAL AND INSTALLATION PASSENGER AIR BAG CUT OFF SWITCH INSPECTION AIR BAG MODULE AND SEAT BELT PRE-TENSIONER DISPOSAL PROCEDURESBATTERYIGNITION SWITCH SPECIAL TOOL(S)TROUBLESHOOTING ENCRYPTED CODE REGISTRATION CRITERIA TABLE DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES B1721 TRANSPONDER BASESTATION FAILURE B1722 TRANSPONDER ANTENNA FAILURE B1723 TRANSPONDER COMMUNICATION FAILURE B1725 ENGINE-ECU OR ENGINE-TRANSMISSION-ECU MODE ERROR B1731 IMMOBILIZER COMMUNICATION FAILURE SYMPTOM CHARTSYMPTOM PROCEDURES Ignition Key cannot be Registered with M.U.T.-III ENGINE DOES NOT START (CRANKING BUT NO INITIAL COMBUSTION) MALFUNCTION OF THE IGNITION SWITCH POWER SUPPLY SYSTEM DATA LIST REFERENCE TABLEON-VEHICLE SERVICEIGNITION SWITCHCOMBINATION METER SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHART<COLT> DIAGNOSIS CODE CHART<COLT CZ3>DIAGNOSIS CODE PROCEDURES<COLT> B1011,B1012 AMBIENT TEMPERATURE SENSOR CIRCUIT LOW OR HIGH B1200 DEFECTIVE ODOMETER B1201 FUEL SYSTEM INFORMATION ERROR U1073 BUS OFF U1100, 1101 TIME-OUT DURING CAN COMMUNICATION WITH ENGINE-A/T-ECU U1102 TIME-OUT DURING CAN COMMUNICATION WITH ABS-ECU U1106 TIME-OUT DURING CAN COMMUNICATION WITH EPS-ECU U1109 TIME-OUT DURING CAN COMMUNICATION WITH ETACS-ECU U1112 TIME-OUT DURING CAN COMMUNICATION WITH SRS-ECU U1120 INFORMATION ON FAILURES IN ENGINE CONTROL SYSTEM VIA CAN COMMUNICATION U1121 INFORMATION ON FAILURES IN CVT CONTROL SYSTEM VIA CAN COMMUNICATION U1122 INFORMATION ON FAILURES IN ABS-ECU VIA CAN COMMUNICATION U1132 SRS-ECU CAN communication failure information U1206 INCONSISTENCY BETWEEN COMMUNICATION WAITING SIGNAL FLAGSDIAGNOSIS CODE PROCEDURES<COLT CZ3> B1011,B1012 AMBIENT TEMPERATURE SENSOR CIRCUIT LOW OR HIGH B1200 DEFECTIVE ODOMETER B1201 FUEL SYSTEM INFORMATION ERROR U1073 BUS OFF U1100, 1101 TIME-OUT DURING CAN COMMUNICATION WITH ENGINE-A/T-ECU U1102 TIME-OUT DURING CAN COMMUNICATION WITH ABS-ECU U1106 TIME-OUT DURING CAN COMMUNICATION WITH EPS-ECU U1109 TIME-OUT DURING CAN COMMUNICATION WITH ETACS-ECU U1112 TIME-OUT DURING CAN COMMUNICATION WITH SRS-ECU U1120 INFORMATION ON FAILURES IN ENGINE CONTROL SYSTEM VIA CAN COMMUNICATION U1121 INFORMATION ON FAILURES IN CVT CONTROL SYSTEM VIA CAN COMMUNICATION U1122 INFORMATION ON FAILURES IN ABS-ECU VIA CAN COMMUNICATION U1132 SRS-ECU CAN communication failure information U1206 INCONSISTENCY BETWEEN COMMUNICATION WAITING SIGNAL FLAGS SYMPTOM CHART<COLT> SYMPTOM CHART<COLT CZ3>SYMPTOM PROCEDURES<COLT> COMMUNICATION WITH M.U.T.-III IS NOT POSSIBLE POWER SUPPLY CIRCUIT SPEEDOMETER DOES NOT WORK. TACHOMETER DOES NOT WORK. FUEL GAUGE DOES NOT WORK. WARNING BUZZER DOES NOT SOUND THE LCD SCREEN DOES NOT SWITCH TO THE FUEL CONSUMPTION DISPLAY.SYMPTOM PROCEDURES<COLT CZ3> COMMUNICATION WITH M.U.T.-III IS NOT POSSIBLE POWER SUPPLY CIRCUIT SPEEDOMETER DOES NOT WORK. TACHOMETER DOES NOT WORK. FUEL GAUGE DOES NOT WORK. WARNING BUZZER DOES NOT SOUND THE LCD SCREEN DOES NOT SWITCH TO THE FUEL CONSUMPTION DISPLAY. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICECOMBINATION METERHEADLAMPFRONT FOG LAMP SERVICE SPECIFICATION(S) SPECIAL TOOL(S) TROUBLESHOOTINGON-VEHICLE SERVICEFOG LAMPFOG LAMP SWITCHREAR FOG LAMPSIDE TURN-SIGNAL LAMPROOM LAMP SPECIAL TOOL(S) TROUBLESHOOTING ACTUATOR TEST REFERENCE TABLE SYMPTOM CHARTSYMPTOM PROCEDURES ROOM LAMP REMOVAL AND INSTALLATION LUGGAGE COMPARTMENT LAMP REMOVAL AND INSTALLATIONREAR COMBINATION LAMP SPECIAL TOOL(S) TROUBLESHOOTINGREAR COMBINATION LAMP REAR COMBINATION LAMP REMOVAL AND INSTALLATION<COLT> REAR COMBINATION LAMP REMOVAL AND INSTALLATION<COLT CZ3/CZT>TAIL LAMP<COLT CZ3>HIGH-MOUNTED STOP LAMP HIGH-MOUNTED STOP LAMP REMOVAL AND INSTALLATION<COLT> HIGH-MOUNTED STOP LAMP REMOVAL AND INSTALLATION<COLT-CZ3>LICENCE PLATE LAMPHAZARD WARNING LAMP SWITCHCOLUMN SWITCHHORNRADIO WITH CD PLAYER SPECIAL TOOL(S)TROUBLESHOOTINGSYMPTOM PROCEDURES WHEN POWER SWITCH IS TURNED "ON," NO POWER IS AVAILABLE<Vehicle without Auto Stop & Go (AS&G) System> WHEN POWER SWITCH IS TURNED "ON," NO POWER IS AVAILABLE<Vehicle with Auto Stop & Go (AS&G) System> WHEN THE ENGINE IS STARTED BY THE AUTO STOP AND GO (AS AND G) SYSTEM, THE SOUND OF THE RADIO WITH CD PLAYER IS INTERRUPTED. NO SOUND FROM ONE SPEAKER.<COLT> NO SOUND FROM ONE SPEAKER.<COLT CZ3> NOISE APPEARS AT CERTAIN PLACES WHEN TRAVELING. MIXED WITH NOISE, ONLY AT NIGHT. BROADCASTS CAN BE HEARD BUT BOTH LW/MW/FM HAVE A LOT OF NOISE. THERE IS NOISE WHEN STARTING THE ENGINE. SOME NOISE APPEARS WHEN THERE IS VIBRATION OR SHOCKS DURING TRAVELING EVER-PRESENT NOISE THERE IS NOISE BUT NO RECEPTION FOR BOTH LW/MW/FM OR NO SOUND FROM LW/MW/FM. POOR RECEPTION. DISTORTION ON LW/MW/FM. USING THE AUTO SELECT FUNCTION, TOO FEW AUTOMATIC STATIONS ARE SELECTED PRESET STATIONS ARE ERASED. CD CANNOT BE INSERTED. NO SOUND (CD ONLY). CD SOUND SKIPS. SOUND QUALITY IS POOR. CD CANNOT BE EJECTED.ON-VEHICLE SERVICERADIO WITH CD PLAYERSPEAKERANTENNASTEERING WHEEL AUDIO REMOTE CONTROL SWITCHTROUBLESHOOTINGSYMPTOM PROCEDURES STEERING WHEEL AUDIO REMOTE CONTROL SWITCH DOES NOT FUNCTION. STEERING WHEEL AUDIO REMOTE CONTROL SWITCH ILLUMINATION DOES NOT COME ON. STEERING WHEEL AUDIO REMOTE CONTROL SWITCH REMOVAL AND INSTALLATION STEERING WHEEL AUDIO REMOTE CONTROL SWITCH INSPECTIONREAR WINDOW DEFOGGERETACS-ECUAMBIENT TEMPERATURE SENSOR GENERAL INFORMATION SPECIAL TOOLSTROUBLESHOOTING BEFORE COMMENCING TROUBLESHOOTING STANDARD FLOW OF DIAGNOSTIC TROUBLE SHOOTING DIAGNOSTIC FUNCTIONS SERVICE DATA REFERENCE TABLE ACTUATOR TEST TABLE DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES DIAGNOSIS CODE No.B1709 ETACS-ECU (EEPROM) DIAGNOSIS CODE NO.B1728, B1729 MALFUNCTION OF THE POWER SUPPLY TO THE ETACS-ECU DIAGNOSIS CODE NO.B1740, B1741 BLOWN TURN-SIGNAL LAMP BULB<COLT> DIAGNOSIS CODE NO.B1740, B1741 BLOWN TURN-SIGNAL LAMP BULB<COLT CZ3> DIAGNOSIS CODE NO.B1742 MALFUNCTION OF THE TURN-SIGNAL LAMP SWITCH DIAGNOSIS CODE NO.B1743 BLOWN HAZARD WARNING LAMP FUSE DIAGNOSIS CODE NO.B1760, B1761 VEHICLE INFORMATION NOT REGISTERED DIAGNOSIS CODE NO.U1073 BUS OFF DIAGNOSIS CODE NO.U1100, U1101 ENGINE-ECU TIME-OUT DIAGNOSIS CODE NO.U1102 ABS-ECU or ACTIVE STABILITY CONTROL SYSTEM-ECU TIME-OUT DIAGNOSIS CODE NO.U1108 COMBINATION METER TIME-OUT DIAGNOSIS CODE NO.U1112 SRS-ECU TIME-OUT DIAGNOSIS CODE NO.U1121 FAILURE INFORMATION ON ENGINE-ECU DIAGNOSIS CODE NO.U1128 FAILURE INFORMATION ON COMBINATION METER DIAGNOSIS CODE NO.U1500 COLUMN SWITCH TIME-OUT DIAGNOSIS CODE No.U1504 RAIN LIGHT SENSOR TIME-OUT DIAGNOSIS CODE NO.U1507 ETACS-ECU TRANSMISSION ERROR DIAGNOSIS CODE No.U1550 AUTO LIGHT SENSOR FAIL U1401 Dynamic range error SYMPTOM CHART INPUT SIGNAL CHARTSYMPTOM PROCEDURES CHECK THE CIRCUIT (POWER SUPPLY LINE) FROM BATTERYBUZZER LAMP REMINDER BUZZER FUNCTION DOES NOT WORK NORMALLY. TURN-SIGNAL LAMP OPERATION SOUND FUNCTION DOES NOT WORK NORMALLY. SEAT BELT REMINDER FUNCTION DOES NOT WORK NORMALLY.WINDSHIELD WIPER/WASHER THE WINDSHIELD WIPERS DO NOT WORK AT ALL. THE WINDSHIELD WIPERS DO NOT WORK NORMALLY. THE WINDSHIELD WIPERS DO NOT STOP AT THE SPECIFIED PARK POSITION. THE INTERMITTENT WIPER INTERVAL CANNOT BE ADJUSTED BY OPERATING THE WINDSHIELD INTERMITTENT WIPER VOLUME CONTROL. THE INTERMITTENT WIPER INTERVAL IS NOT CHANGED ACCORDING TO THE VEHICLE SPEED. THE WINDSHIELD WASHER DOES NOT WORK NORMALLY. THE WINDSHIELD WIPERS COMPATIBLE WITH THE RAIN LIGHT SENSOR DO NOT OPERATE NORMALLY.REAR WIPER/WASHER THE REAR WIPER DOES NOT WORK NORMALLY.<COLT> THE REAR WIPER DOES NOT WORK NORMALLY.<COLT CZ3> THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION.<COLT> THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION.<COLT CZ3> THE REAR WASHER DOES NOT WORK NORMALLY.HEADLAMP AND TAIL LAMP THE TAIL LAMPS DO NOT ILLUMINATE NORMALLY. THE LOW-BEAM HEADLAMPS DO NOT ILLUMINATE. THE HIGH-BEAM HEADLAMPS DO NOT ILLUMINATE. THE HIGH-BEAM AND LOW-BEAM HEADLAMPS DO NOT ILLUMINATE WHEN THE PASSING SWITCH IS OPERATED. ANY OF TAIL LAMPS DOES NOT ILLUMINATE.<COLT> ANY OF TAIL LAMPS DOES NOT ILLUMINATE.<COLT CZ3> ANY OF THE HEADLAMPS DOES NOT ILLUMINATE. THE HIGH-BEAM INDICATOR DOES NOT ILLUMINATE OR GO OUT NORMALLY. THE DAYTIME RUNNING LAMP DOES NOT WORK NORMALLY. THE TAIL LAMPS AND THE HEADLAMPS KEEP ILLUMINATING WHEN THE IGNITION SWITCH IS IN THE "ON" POSITION. AUTO LAMP FUNCTION DOES NOT WORK NORMALLY. THE COMING HOME LIGHT DOES NOT WORK NORMALLY.TURN-SIGNAL LAMP THE TURN-SIGNAL LAMPS DO NOT ILLUMINATE NORMALLY. ANY OF THE TURN-SIGNAL LAMPS DOES NOT ILLUMINATE. THE TURN-SIGNAL LAMP INDICATOR DOES NOT ILLUMINATE OR GO OUT NORMALLY. THE COMFORT FLASHING FUNCTION DOES NOT WORK NORMALLY. THE HAZARD WARNING LAMPS DO NOT ILLUMINATE NORMALLY. THE ESS DOES NOT WORK NORMALLY.FOG LAMP THE FRONT FOG LAMPS DO NOT ILLUMINATE NORMALLY. THE REAR FOG LAMPS DO NOT ILLUMINATE NORMALLY.<COLT> THE REAR FOG LAMPS DO NOT ILLUMINATE NORMALLY.<COLT CZ3> ANY OF THE FRONT FOG LAMPS DOES NOT ILLUMINATE. THE FRONT FOG LAMP INDICATOR DOES NOT ILLUMINATE. THE REAR FOG LAMP INDICATOR DOES NOT ILLUMINATE. ONLY SPECIFIC FUNCTION(S) WORKS (FAIL-SAFE STATE).INPUT SIGNAL PROCEDURES THE COLUMN SWITCH (LIGHTING AND WIPER SWITCH) SIGNAL IS NOT RECEIVED. THE IGNITION SWITCH (ACC) SIGNAL IS NOT RECEIVED. THE IGNITION SWITCH (IG1) SIGNAL IS NOT RECEIVED. THE HAZARD WARNING LAMP SWITCH SIGNAL IS NOT RECEIVED. THE FRONT FOG LAMP SWITCH SIGNAL IS NOT RECEIVED. THE REAR FOG LAMP SWITCH SIGNAL IS NOT RECEIVED. THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT (LH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT CZ3 (LH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT (RH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT CZ3 (RH drive vehicles)> CHECK AT ECU TERMINALON-VEHICLE SERVICE GENERAL INFORMATION SPECIAL TOOL(S) TEST EQUIPMENT SERVICE PRECAUTIONS PRECAUTIONS ON HOW TO REPAIR THE CAN BUS LINES EXPLANATION ABOUT THE M.U.T.-III CAN BUS DIAGNOSTICSTROUBLESHOOTING CAN BUS DIAGNOSIS CHARTCAN BUS DIAGNOSIS DIAGNOSIS ITEM 1 DIAGNOSIS ITEM 2 DIAGNOSIS ITEM 3 DIAGNOSIS ITEM 4 DIAGNOSIS ITEM 5 DIAGNOSIS ITEM 6 DIAGNOSIS ITEM 7 DIAGNOSIS ITEM 8 DIAGNOSIS ITEM 9 DIAGNOSIS ITEM 10 DIAGNOSIS ITEM 11 DIAGNOSIS ITEM 12 DIAGNOSIS ITEM 13 DIAGNOSIS ITEM 19 DIAGNOSIS ITEM 20 DIAGNOSIS ITEM 21 DIAGNOSIS ITEM 22 DIAGNOSIS ITEM 23 DIAGNOSIS ITEM 24 DIAGNOSIS ITEM 25 DIAGNOSIS ITEM 26 DIAGNOSIS ITEM 27 DIAGNOSIS ITEM 28 DIAGNOSIS ITEM 29 CAN COMMUNICATION-RELATED DIAGNOSIS CODE TABLE GENERAL INFORMATION SERVICE SPECIFICATION(S) TROUBLESHOOTING CHECK AT ECU TERMINALON-VEHICLE SERVICEHEATER CONTROL ASSEMBLY HEATER CONTROL ASSEMBLY REMOVAL AND INSTALLATION INSPECTION HEATER CONTROL ASSEMBLY DISASSEMBLY AND REASSEMBLYHEATER UNIT AND AIR INTAKE BOX HEATER UNIT AND AIR INTAKE BOX REMOVAL AND INSTALLATION HEATER UNIT DISASSEMBLY AND ASSEMBLY AIR INTAKE BOX DISASSEMBLY AND REASSEMBLYBLOWER MOTOR, RESISTOR AND OUTSIDE/INSIDE AIR SELECTION DAMPER CONTROL MOTOR BLOWER MOTOR AND RESISTOR REMOVAL AND INSTALLATION<LHD> BLOWER MOTOR AND RESISTOR REMOVAL AND INSTALLATION<RHD> INSPECTIONDUCTSVENTILATORS SERVICE PRECAUTIONS GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES B1001 INTERIOR TEMPERATURE SENSOR SYSTEM B1021 AIR THERMO SENSOR SYSTEM B1084 REAR WINDOW DEFOGGER OUTPUT SYSTEM B1086 MOTOR OUTPUT SYSTEM FOR AIR OUTSIDE/INSIDE AIR CIRCULATION SWITCHING DAMPER B1088 MOTOR POTENTIOMETER SYSTEM FOR AIR MIX DAMPER B1090 MOTOR DRIVE SYSTEM FOR AIR MIX DAMPER B1092 POOR RECEPTION OF ETACS SIGNAL U1073 BUS OFF ERROR U1100 ENGINE CAN COMMUNICATION TIME-OUT U1108 COMBINATION METER CAN COMMUNICATION TIME-OUT U1109 ETACS CAN COMMUNICATION TIME-OUT U1401 Dynamic range error SYMPTOM CHART<EXCEPT 1500 T/C>SYMPTOM PROCEDURES<EXCEPT 1500 T/C> COMMUNICATION WITH THE SCAN TOOL IS NOT POSSIBLE.<Petrol powered vehicles except 4G1> BLOWER FAN AND MOTOR DOES NOT RUN. BLOWER FAN AND MOTOR DOES NOT STOP TURNING. DEFROSTER FUNCTION DOES NOT OPERATE. DEFOGGER TIMER DOES NOT FUNCTION. AIR CONDITIONING DOES NOT OPERATE. A/C OUTLET AIR TEMPERATURE DOES NOT INCREASE THE A/C INDICATOR FLASHES. A/C PRESSURE SENSOR SYSTEM MALFUNCTION OF THE A/C-ECU POWER SUPPLY SYSTEM SYMPTOM CHART<1500 T/C>SYMPTOM PROCEDURES<1500 T/C> COMMUNICATION WITH THE SCAN TOOL IS NOT POSSIBLE.<1500 T/C> AIR CONDITIONING DOES NOT OPERATE.<1500 T/C> DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE SIGHT GLASS REFRIGERANT LEVEL TEST COMPRESSOR DRIVE BELT ADJUSTMENT SIMPLE INSPECTION OF THE A/C PRESSURE SENSOR CHARGING <VEHICLES USING R-134a REFRIGERANT> REFRIGERANT DISCHARGE REFILLING OF OIL IN THE A/C SYSTEM PERFORMANCE TEST <VEHICLES USING R-134a REFRIGERANT> POWER RELAY CHECK IDLE-UP OPERATION CHECK CLEAN AIR FILTER REPLACEMENT PROCEDURESEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY SEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY REMOVAL AND INSTALLATION INSPECTION SEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY DISASSEMBLY AND REASSEMBLYHEATER UNIT AND AIR INTAKE BOX HEATER UNIT AND AIR INTAKE BOX REMOVAL AND INSTALLATION HEATER UNIT DISASSEMBLY AND REASSEMBLY AIR INTAKE BOX DISASSEMBLY AND REASSEMBLYAIR MIXING DAMPER CONTROL MOTORSENSORSCOMPRESSOR ASSEMBLY COMPRESSOR ASSEMBLY REMOVAL AND INSTALLATION COMPRESSOR ASSEMBLY INSPECTION COMPRESSOR ASSEMBLY DISASSEMBLY AND ASSEMBLY COMPRESSOR ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)CONDENSER ASSEMBLYREFRIGERANT LINEOTHER PARTS RELAY ECU SENSOR SOLENOID AND SOLENOID VALVE INSPECTION CONNECTOR AND SPARE CONNECTOR FUSIBLE LINK AND FUSE DIODE LOCATION EARTH CABLE EARTHOVERALL CONFIGURATION DIAGRAM OVERALL CONFIGURATION DIAGRAM<COLT (LH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT (RH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT CZ3 (LH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT CZ3 (RH drive vehicles)>ENGINE COMPARTMENT ENGINE COMPARTMENT<134, 3A9 (LH drive vehicles)> ENGINE COMPARTMENT<3A9 (RH drive vehicles)> ENGINE COMPARTMENT<135, 4A9 (LH drive vehicles)> ENGINE COMPARTMENT<4A9 (RH drive vehicles)> ENGINE COMPARTMENT<4G1 (LH drive vehicles)> ENGINE COMPARTMENT<4G1 (RH drive vehicles)>INSTRUMENT PANELFLOOR AND ROOFDOOR DOOR<COLT (LH drive vehicles)> DOOR<COLT (RH drive vehicles)> DOOR<COLT CZ3 (LH drive vehicles)> DOOR<COLT CZ3 (RH drive vehicles)>TAILGATE JUNCTION BLOCK (J/B) JOINT CONNECTOR (J/C) CENTRALIZED JUNCTION POWER DISTRIBUTION SYSTEMSTARTING SYSTEM STARTING SYSTEM<134, 3A9, 135, 4A9 (VEHICLES WITHOUT AS&G)> STARTING SYSTEM<3A9, 4A9 (VEHICLES WITH AS&G)> STARTING SYSTEM<4G1>IGNITION SYSTEM IGNITION SYSTEM<134> IGNITION SYSTEM<3A9> IGNITION SYSTEM<135> IGNITION SYSTEM<4A9> IGNITION SYSTEM<4G1>CHARGING SYSTEM CHARGING SYSTEM<134, 3A9, 135, 4A9 (VEHICLES WITHOUT AS&G)> CHARGING SYSTEM<3A9, 4A9 (VEHICLES WITH AS&G)> CHARGING SYSTEM<4G1>ENGINE CONTROL SYSTEMCOOLING SYSTEM AUTOMATED MANUAL TRANSMISSION SYSTEM HEADLAMPTAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<COLT> TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<COLT CZ3> FRONT FOG LAMPREAR FOG LAMPROOM LAMP AND LUGGAGE COMPARTMENT LAMP ROOM LAMP AND LUGGAGE COMPARTMENT LAMP<LH DRIVE VEHICLES> ROOM LAMP AND LUGGAGE COMPARTMENT LAMP<RH DRIVE VEHICLES> HEADLAMP LEVELLING SYSTEM TURN-SIGNAL LAMP AND HAZARD WARNING LAMP STOP LAMPBACK-UP LAMP HORNMETER AND GAUGEFUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP FUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP<134, 3A9, 135, 4A9> FUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP<4G1>POWER WINDOWSCENTRAL DOOR LOCKING SYSTEM CENTRAL DOOR LOCKING SYSTEM<COLT (LH DRIVE VEHICLES)> CENTRAL DOOR LOCKING SYSTEM<COLT (RHD WITHOUT DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT (RHD WITH DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3 (LH DRIVE VEHICLES)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3 (RHD WITHOUT DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3 (RHD WITH DEADLOCK SYSTEM)> HEATERSEMI-AUTOMATIC AIR CONDITIONERWINDSHIELD WIPER AND WASHER REAR WIPER AND WASHERREMOTE CONTROLLED MIRRORREAR WINDOW DEFOGGER AND DOOR MIRROR HEATER REAR WINDOW DEFOGGER AND DOOR MIRROR HEATER<LH DRIVE VEHICLES> REAR WINDOW DEFOGGER AND DOOR MIRROR HEATER<RH DRIVE VEHICLES>AUDIO SYSTEM AUDIO SYSTEM<COLT (LH DRIVE VEHICLES)> AUDIO SYSTEM<COLT (RH DRIVE VEHICLES)> AUDIO SYSTEM<COLT CZ3 (LH DRIVE VEHICLES)> AUDIO SYSTEM<COLT CZ3 (RH DRIVE VEHICLES)> ACCESSORY SOCKET ANTI-SKID BRAKING SYSTEM (ABS)<134, 3A9, 135, 4A9>ANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC) ANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC)<134, 3A9, 135, 4A9> ANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC)<4G1>ELECTRIC POWER STEERING SYSTEM SUPPLEMENTAL RESTRAINT SYSTEM (SRS)CRUISE CONTROL SYSTEMIMMOBILIZER SYSTEM IMMOBILIZER SYSTEM<134, 3A9, 135, 4A9 (LH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<3A9, 4A9 (RH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<4G1 (LH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<4G1 (RH DRIVE VEHICLES)> HEATED SEATCONTROLLER AREA NETWORK (CAN)SEAT BELT WARNING BUZZER AUTO STOP AND GO (AS&G) SYSTEM EMERGENCY STOP SIGNAL SYSTEM