SPECIFICATIONS
A/C SYSTEM
| Item |
Description |
Notes |
| A/C Compressor |
Denso 5SE12C |
ND-8 PAG oil |
| Freeze-up Control |
Evaporator temperature sensor |
Input to A/C-heater control, HVAC housing mounted, sets compressor to destroke 2° C (36° F) below evaporator target temperature (minimum 5°
C (41° F)) and activates compressor when within 1° C (34° F) of evaporator target temperature |
| Low psi Control |
A/C pressure transducer |
Input to PCM/ECM, discharge line mounted, sets compressor to destroke below 200 kPa (29 psi), activates compressor above 234 -262 kPa (34 - 38 psi) |
| High psi Control |
A/C pressure transducer |
Input to PCM/ECM, discharge line mounted - compressor to destroke above 3130 kPa (454 psi) and below 200 kPa (29 psi) |
| R-134a Refrigerant Charge Capacity |
0.51 kg (1.125 lbs.) |
Also see A/C Underhood Specification Label located in the engine compartment |
TORQUE
| Description |
N·m |
Ft. Lbs. |
In. Lbs. |
| All Screws NOT Listed Below |
2 |
— |
17 |
| A/C Accumulator Bracket Bolts |
15 |
11 |
— |
| A/C Accumulator Retaining Band Bolt |
8 |
— |
71 |
| A/C Compressor to Engine Bolts |
25 |
18 |
— |
| Air Distribution Housing Halves Screws |
1.2 |
— |
10 |
| Air Distribution Housing to HVAC Housing Screws |
1.2 |
— |
10 |
| Air Inlet Housing to HVAC Housing Screws |
1.2 |
— |
10 |
| Blend Door Lever Screw |
0.6 |
— |
5 |
| Blower Motor Screws |
1.2 |
— |
10 |
| Center Duct Screws |
2.2 |
— |
20 |
| Defroster Duct Support Screws |
3 |
— |
27 |
| Defroster Duct Screws |
2.2 |
— |
20 |
| Demister Duct Screws |
2.2 |
— |
20 |
| Flange to HVAC Housing Screw |
1.2 |
— |
10 |
| Heater Core Tube Retaining Bracket Screw |
1.2 |
— |
10 |
| Heat Shield to Dash Panel Nuts |
1 |
— |
10 |
| HVAC Housing Halves Screws |
1.2 |
— |
10 |
| HVAC Housing to Dash Panel Nut |
4.5 |
— |
40 |
| Lower Condenser Bracket to Radiator Bolts |
4.5 |
— |
40 |
| Mode Door Cam Screw |
0.6 |
— |
5 |
| PTC Heater Unit to Housing Screws |
1.2 |
— |
10 |
| Rear Seat Floor Duct Screw |
2.2 |
— |
20 |
| Refrigerant Lines to A/C Evaporator Bolt |
12 |
— |
105 |
| Refrigerant Lines to Compressor Nuts |
20 |
15 |
— |
| Refrigerant Lines to A/C Condenser Nuts |
5 |
— |
44 |
| Refrigerant Line Bracket to Strut Tower Nut |
4.5 |
— |
40 |
| Suction Line to Accumulator Nut |
5 |
— |
44 |