Engine Repair Manual [ 2UZ-FE ]
INTRODUCTION
HOW TO USE THIS MANUAL
IDENTIFICATION INFORMATION
REPAIR INSTRUCTIONS
FOR ALL OF VEHICLES
HOW TO TROUBLESHOOT ECU CONTROLLED SYSTEMS
- GENERAL INFORMATION ( 2001.8 - ) · PDF
- HOW TO PROCEED WITH TROUBLESHOOTING ( 2001.8 - ) · PDF
- HOW TO USE THE DIAGNOSTIC CHART AND INSPECTION PROCEDURE ( 2001.8 - ) · PDF
TERMS
PREPARATION
EMISSION CONTROL
CHARGING
SERVICE SPECIFICATIONS
STANDARD BOLT
- HOW TO DETERMINE BOLT STRENGTH ( 2001.8 - ) · PDF
- SPECIFIED TORQUE FOR STANDARD BOLTS ( 2001.8 - ) · PDF
- HOW TO DETERMINE NUT STRENGTH ( 2001.8 - ) · PDF
EMISSION CONTROL
CHARGING
DIAGNOSTICS
ENGINE
- HOW TO PROCEED WITH TROUBLESHOOTING ( 2001.8 - ) · PDF
- CUSTOMER PROBLEM ANALYSIS CHECK ( 2001.8 - ) · PDF
- PRE-CHECK ( 2001.8 - ) · PDF
- DIAGNOSTIC TROUBLE CODE CHART ( 2001.8 - ) · PDF
- PARTS LOCATION ( 2001.8 - ) · PDF
- TERMINALS OF ECU ( 2001.8 - ) · PDF
- PROBLEM SYMPTOMS TABLE ( 2001.8 - ) · PDF
- P0116/22 Engine Coolant Temp. Circuit Range/ Performance Problem ( 2001.8 - ) · PDF
- P0125/91 Insufficient Coolant Temp. for Closed Loop Fuel Control ( 2001.8 - ) · PDF
- P0133/21 Oxygen Sensor Circuit Slow Response (Bank 1 Sensor 1) ( 2001.8 - ) · PDF
- P0135/21 Oxygen Sensor Heater Circuit Malfunction (Bank 1 Sensor 1) ( 2001.8 - ) · PDF
- P0171/25 Fuel Trim System too Lean (Air-Fuel Ratio Lean Malfunction, Bank 1) ( 2001.8 - ) · PDF
- P0300/93 Random/Multiple Cylinder Misfire Detected ( 2001.8 - ) · PDF
- P0420/94 Catalyst System Efficiency Below Threshold (Bank 1) ( 2001.8 - ) · PDF
- P0443/94 Evaporative Emission Control System Purge Control Vent Control Malfunction ( 2001.8 - ) · PDF
- P0505/33 Idle Control System Malfunction ( 2001.8 - ) · PDF
- P1520/95 Stop Light Switch Signal Malfunction (Only for A/T) ( 2001.8 - ) · PDF
- P1600/96 ECM BATT Malfunction ( 2001.8 - ) · PDF
- P1780/97 Neutral Start Switch Malfunction ( 2001.8 - ) · PDF
- Starter Signal Circuit ( 2001.8 - ) · PDF
- Engine ECU Power Source Circuit ( 2001.8 - ) · PDF