Repair Manual
INTRODUCTION
HOW TO USE THIS MANUAL
IDENTIFICATION INFORMATION
REPAIR INSTRUCTIONS
FOR ALL OF VEHICLES
HOW TO TROUBLESHOOT ECU CONTROLLED SYSTEMS
- GENERAL INFORMATION ( 1999.8 - ) · PDF
- HOW TO PROCEED WITH TROUBLESHOOTING ( 1999.8 - ) · PDF
- HOW TO USE THE DIAGNOSTIC CHART AND INSPECTION PROCEDURE ( 1999.8 - ) · PDF
TERMS
PREPARATION
SUSPENSION AND AXLE
- SST (Special Service Tools) ( 1999.8 - ) · PDF
- RECOMMENDED TOOLS ( 1999.8 - ) · PDF
- EQUIPMENT ( 1999.8 - ) · PDF
- LUBRICANT ( 1999.8 - ) · PDF
- SSM (Special Service Materials) ( 1999.8 - ) · PDF
BRAKE
- SST (Special Service Tools) ( 1999.8 - ) · PDF
- RECOMMENDED TOOLS ( 1999.8 - ) · PDF
- EQUIPMENT ( 1999.8 - ) · PDF
- LUBRICANT ( 1999.8 - ) · PDF
SERVICE SPECIFICATIONS
STANDARD BOLT
- HOW TO DETERMINE BOLT STRENGTH ( 1999.8 - ) · PDF
- SPECIFIED TORQUE FOR STANDARD BOLTS ( 1999.8 - ) · PDF
- HOW TO DETERMINE NUT STRENGTH ( 1999.8 - ) · PDF
SUSPENSION AND AXLE
BRAKE
BODY
DIAGNOSTICS
ABS & VEHICLE STABILITY CONTROL (VSC) & BRAKE ASSIST (BA) SYSTEM
- HOW TO PROCEED WITH TROUBLESHOOTING ( 1999.8 - ) · PDF
- CUSTOMER PROBLEM ANALYSIS CHECK ( 1999.8 - ) · PDF
- PRE-CHECK ( 1999.8 - ) · PDF
- DIAGNOSTIC TROUBLE CODE CHART ( 1999.8 - ) · PDF
- PARTS LOCATION ( 1999.8 - ) · PDF
- TERMINALS OF ECU ( 1999.8 - ) · PDF
- PROBLEM SYMPTOMS TABLE ( 1999.8 - ) · PDF
- C0200/31 to C0215/34 Speed Sensor Circuit ( 1999.8 - ) · PDF
- C0226/21 to C0256/24 ABS Solenoid Circuit ( 1999.8 - ) · PDF
- C0278/11, C0279/12 ABS Solenoid Relay Circuit ( 1999.8 - ) · PDF
- C1201/51 Engine Control System Malfunction ( 1999.8 - ) · PDF
- C1203/53 Engine and ECT ECU Communication Circuit Malfunction ( 1999.8 - ) · PDF
- C1207/37 Neutral Start Switch Circuit (P/R Range) ( 1999.8 - ) · PDF
- C1210/36 Zero Point Calibration of Yaw Rate Sensor Undone ( 1999.8 - ) · PDF
- C1223/43 ABS Control System Malfunction ( 1999.8 - ) · PDF
- C1224/44 NE Signal Circuit ( 1999.8 - ) · PDF
- C1225/25 to C1228/28 TRC & VSC Solenoid Circuit ( 1999.8 - ) · PDF
- C1231/31 Steering Angle Sensor Circuit ( 1999.8 - ) · PDF
- C1232/32 Deceleration Sensor Circuit ( 1999.8 - ) · PDF
- C1233/33, C1234/34 Yaw Rate Sensor Circuit ( 1999.8 - ) · PDF
- C1237/37 Tires of Different Size ( 1999.8 - ) · PDF
- C1241/41 IG Power Source Circuit ( 1999.8 - ) · PDF
- C1242/42 IG2 Power Source Circuit ( 1999.8 - ) · PDF
- C1243/43, C1245/45 Malfunction in Deceleration Sensor ( 1999.8 - ) · PDF
- C1244/44 Deceleration Sensor Circuit ( 1999.8 - ) · PDF
- C1246/46 Master Cylinder Pressure Sensor Circuit ( 1999.8 - ) · PDF
- C1249/49 Stop Light Switch Circuit ( 1999.8 - ) · PDF
- C1251/51 Hydraulic Brake Booster Pump Motor Malfunction ( 1999.8 - ) · PDF
- C1252/52 Hydraulic Brake Booster Pump Motor ON Time Abnormally Long ( 1999.8 - ) · PDF
- C1253/53 Motor Relay Circuit ( 1999.8 - ) · PDF
- C1254/54 Pressure Switch Circuit ( 1999.8 - ) · PDF
- C1256/56 Accumulator Low Pressure Malfunction ( 1999.8 - ) · PDF
- C1257/57 Power Supply Drive Circuit ( 1999.8 - ) · PDF
- C1268/68 Transfer L4 Position Switch Circuit ( 1999.8 - ) · PDF
- C1269/69 Neutral Start Switch Circuit (R Range) ( 1999.8 - ) · PDF
- C1336/39 Zero Point Calibration of Deceleration Sensor Undone ( 1999.8 - ) · PDF
- C1340/47 Center Differential Lock Circuit ( 1999.8 - ) · PDF
- Always ON ( 1999.8 - ) · PDF
- Always ON ( 1999.8 - ) · PDF
- ABS Warning Light Circuit ( 1999.8 - ) · PDF
- VSC TRC Warning Light Circuit ( 1999.8 - ) · PDF
- BRAKE Warning Light Circuit ( 1999.8 - ) · PDF
- SLIP Indicator Light Circuit ( 1999.8 - ) · PDF
- ACTIVE TRC Indicator Light Circuit ( 1999.8 - ) · PDF
- VSC OFF Indicator Light, Center Diff Lock Switch Circuit ( 1999.8 - ) · PDF
- Brake Warning, VSC Buzzer Circuit ( 1999.8 - ) · PDF
- Tc Terminal Circuit ( 1999.8 - ) · PDF
- Ts Terminal Circuit ( 1999.8 - ) · PDF
- Check for Fluid Leakage ( 1999.8 - ) · PDF
SUSPENSION AND AXLE
FRONT DIFFERENTIAL CARRIER (Independent Front Suspension)
BRAKE
BRAKE FLUID (w/ ABS)
BRAKE PEDAL (w/ ABS) ( 1999.8 - )
HYDRAULIC BRAKE BOOSTER
- ON-VEHICLE INSPECTION ( 1999.8 - ) · PDF
- COMPONENTS ( 1999.8 - ) · PDF
- REMOVAL ( 1999.8 - ) · PDF
- DISASSEMBLY ( 1999.8 - ) · PDF
- DISPOSAL ( 1999.8 - ) · PDF
- REASSEMBLY ( 1999.8 - ) · PDF
- INSTALLATION ( 1999.8 - ) · PDF
- INSPECTION ( 1999.8 - ) · PDF