ENGINE ASSEMBLY > INSTALLATION

1. INSTALL ENGINE MOUNTING BRACKET FRONT LH

2. INSTALL ENGINE MOUNTING BRACKET FRONT RH

3. INSTALL CAMSHAFT TIMING OIL CONTROL VALVE

4. INSTALL CRANKSHAFT POSITION SENSOR

5. INSTALL CAMSHAFT POSITION SENSOR

6. INSTALL ENGINE COOLANT TEMPERATURE SENSOR

7. INSTALL KNOCK SENSOR

8. INSTALL NO. 1 WATER BY-PASS PIPE

9. INSTALL ENGINE OIL PRESSURE SWITCH

10. INSTALL NO. 1 IDLER PULLEY

11. INSTALL THERMOSTAT

12. INSTALL WATER INLET

13. INSTALL V-RIBBED BELT TENSIONER

14. INSTALL COMPRESSOR MOUNTING BRACKET (w/ Air Conditioning)

15. INSTALL EXHAUST MANIFOLD

16. INSTALL EXHAUST MANIFOLD HEAT INSULATOR

17. INSTALL INTAKE MANIFOLD

18. INSTALL INJECTOR

19. INSTALL FUEL DELIVERY PIPE

20. INSTALL THROTTLE BODY

21. INSTALL ENGINE WIRE

22. INSTALL GENERATOR

23. INSTALL VENTILATION PIPE

24. INSTALL SPARK PLUG

25. INSTALL IGNITION COIL

26. REMOVE ENGINE FROM ENGINE STAND

27. INSTALL ENGINE ASSEMBLY

28. INSTALL REAR END PLATE

29. INSTALL FLYWHEEL

30. INSTALL CLUTCH DISC

31. INSTALL CLUTCH COVER

32. INSTALL MANUAL TRANSMISSION UNIT

33. INSTALL CLUTCH RELEASE CYLINDER

34. INSTALL STARTER

35. INSTALL PROPELLER SHAFT WITH CENTER BEARING

36. INSTALL FRONT EXHAUST PIPE

37. INSTALL HOOD

38. INSTALL COOLER COMPRESSOR (w/ Air Conditioning)

39. INSTALL OIL DIPSTICK GUIDE

40. INSTALL OIL DIPSTICK

41. INSTALL VANE PUMP

42. CONNECT ENGINE WIRE

43. CONNECT FUEL HOSE

44. CONNECT HOSE

45. INSTALL RADIATOR

46. INSTALL FAN PULLEY

47. INSTALL FAN SHROUD

48. INSTALL DRIVE BELT

49. CONNECT RADIATOR OUTLET HOSE

50. CONNECT RADIATOR INLET HOSE

51. INSTALL RADIATOR GRILLE

52. INSTALL INTAKE AIR CONNECTOR AND AIR CLEANER ASSEMBLY

53. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

54. ADD ENGINE OIL

55. ADD ENGINE COOLANT

56. CHECK FOR FUEL LEAKS

57. CHECK FOR OIL LEAKS

58. CHECK FOR COOLANT LEAKS

59. PERFORM INITIALIZATION

60. INSTALL NO. 1 ENGINE UNDER COVER

61. CHECK IDLE SPEED AND IGNITION TIMING

62. CHECK CO/HC

63. CHECK FUNCTION OF THROTTLE BODY