8v EFI Swap Info
Suzuki Sidekick/Geo Tracker
into a Samurai

 

Pin Wire Color Circuit Notes on what I did.
1 Blue/Black Ignition Power Hook to existing ECM fuse
2  Black/Green ECM Ground  
3 Empty     
4 Empty     
5 Lt. Green/Yellow  EGR Vacuum Valve  
6 Lt Green/Black IAC Valve  
7  Blue/Black Ignition Power Hook to Heater fuse run heart to Defroster fuse
8  Red Injector Power  
9  White Memory Power To Dome fuse
10  Black/Blue Ground  
11  Black Yellow Crank Signal to black/yellow in plug on right of glovebox
12 Black/Red  Park/Neutral (Auto Only)  
13  Purple/Yellow Check Engine Lamp To sensor lamp wire at old ECM plug
14  Lt Green/White Throttle Opener valve  
15  Blue Main Relay  
16 Pink Fuel Pump Relay Control Used existing relay from geo
17  Yellow Fuel Injector Control  

Pin Wire Color Circuit Notes on what I did.
1 Brown Tach Signal Splice to tach wire in instrument cluster
2 Yellow/Black A/C On Signal  
3 Blue/Yellow Diag Request Left OE Diag connector alone, but stuck it under the dash
4 Black/Green Ground (Calif only)  
5 Emply    
6 Blue/Orange Power Steering Idle Up to power steering box
7 Blue/Red Test  Switch Signal  
8 Lt Green/Red Evap Can Purge Soleniod  
9 Purple Duty Check Output  
10 Empty    
11 White/Yellow TCC Relay (Auto)  
12 Orange Igniter Driver  
13 White CMP Sensor  
14 Blue/White Idle Switch  
15 Yellow VSS input To new VSS output in dash harness
16 Red/Green EGR Temp Sensor (Calif)  
17 Red/Black IAT Input  
18 Red/Yellow Temp Sensor  
19 Yellow/Blue O2 Sensor  
20 Purple/Yellow Serial Data Output  
21 Gray Throttle Position input  
22 Gray/Green MAP Input  
23 Gray/Red Ref 5V  
24 Gray/Yellow Sensor Ground  

Pin Wire Color Circuit Notes on what I did.
1 Black/Green Grounds  
2 Yellow/Black Oil Pressure Remove & use stock Samurai one.
3 Black/Yellow Crank Signal Remove & use stock Samurai one.
4 Lt Green/White Throttle Opener Valve  
5 Orange/Black 4wd Switch Remove & use stock Samurai one.
6 Red Backup Lamp Switch Remove & use stock Samurai one.
7 Yellow/White Temp Sensor  
8 Black/White Generator Remove & use stock Samurai one.
9 Lt Green/Yellow EGR SV Valve  
10 Orange/White Not Used ??
11 Yellow Backup Lamp Remove & use stock Samurai one.
12 White/Red Generator Remove & use stock Samurai one.
13 Lt Green/Red FI Fuse  
14 Lt Blue TCC (Auto Only)  
15 White TCC (Auto Only)  
16 Empty    
17 Black/Red Park/Neutral Switch (Auto Only)  
18 Blue/Red Park/Neutral Switch (Auto Only)  
19      
20 Black/Green Distributor Ground  
21 White Distributor  
22 Black/Green Ground  

Wiring Diagrams:
Click for Image
Power, Ground, MIL, Diags
Page 8A-20-0
Power, Ground, MIL, Diags
Page 8A-20-1
Transmission and Emissions
Page 8A-20-2
Transmission and Emissions
Page 8A-20-3
Fuel Pump and Idle speed controls
Page 8A-20-4
Fuel Pump and Idle speed controls
Page 8A-20-5
Ignition
Page 8A-20-6
Ignition
Page 8A-20-7
Engine & Vehicle Data Sensors
Page 8A-20-8