BRAKE
BRAKE CONTROL
ELECTRONICALLY CONTROLLED BRAKE SYSTEM
- PRECAUTION · Precautions
- PARTS LOCATION · Parts location
- SYSTEM DIAGRAM · System information
- TERMINALS OF ECU · System information
- FAIL-SAFE CHART · System information
- DATA LIST / ACTIVE TEST · System information
- SYSTEM DESCRIPTION · Troubleshooting
- HOW TO PROCEED WITH TROUBLESHOOTING · Troubleshooting
- CHECK FOR INTERMITTENT PROBLEMS · Troubleshooting
- INITIALIZATION · Troubleshooting
- CALIBRATION · Troubleshooting
- TEST MODE PROCEDURE · Troubleshooting
- PROBLEM SYMPTOMS TABLE · Troubleshooting
- DIAGNOSIS SYSTEM · Troubleshooting
- DTC CHECK / CLEAR · Troubleshooting
- FREEZE FRAME DATA · Troubleshooting
- DIAGNOSTIC TROUBLE CODE CHART · Diagnostic trouble codes
- C0200/31 At a vehicle speed of 6 mph (10 km/h) or more, an open or short in the sensor signal circuit of the abnormal... · Diagnostic trouble codes
- C0210/33 At a vehicle speed of 6 mph (10 km/h) or more, an open or short in the sensor signal circuit of the abnormal... · Diagnostic trouble codes
- C1202/68 Pump motor operates for specified period when reservoir level drops. Brake operation signal is input when the... · Diagnostic trouble codes
- C1203/95 No stored information for destination. No stored information whether VSC is in operation or not. Destination... · Diagnostic trouble codes
- C1210/36 Yaw rate sensor zero point calibration is unfinished. · Diagnostic trouble codes
- C1231/31 Steering angle sensor malfunction signal is received when data transmission is valid (internal malfunction is... · Diagnostic trouble codes
- C1234/34 Malfunction signal that is detected at sensor self-check is received when communication with the sensors is... · Diagnostic trouble codes
- C1235/35 Pulse waveform of speed sensor signal is abnormal for at least 5 sec. when vehicle speed is 12 mph (20 km/h)... · Diagnostic trouble codes
- C1241/41 System 1 is under the following conditions when the vehicle is in the READY-on state: Linear solenoid cannot... · Diagnostic trouble codes
- C1246/46 Sensor power source 1 (VCM1) voltage is less than 4.7 V or 5.3 V or more for at least 0.05 sec. · Diagnostic trouble codes
- C1247/47 Sensor power source voltage (VCSK) is 3.6 V or less or 4.95 V or more for at least 1.2 sec. · Diagnostic trouble codes
- C1249/49 Stop light switch circuit is open for at least 10 sec. when IG1 terminal voltage is between 9.5 V and 17.2 V · Diagnostic trouble codes
- C1252/52 Motor relay is ON for at least 5 min. · Diagnostic trouble codes
- C1256/57 Braking operation is input when accumulator pressure is less than 12.45 MPa and vehicle speed is input... · Diagnostic trouble codes
- C1259/58 The regeneration malfunction signal is input for at least 0.02 sec. when IG2 terminal voltage is 9.5 V or... · Diagnostic trouble codes
- C1300 Malfunction in skid control ECU · Diagnostic trouble codes
- C1311/11 Relay contact is off (BS 1 terminal is less than 3.5 V) for at least 0.2 sec. when R1+ terminal voltage is... · Diagnostic trouble codes
- C1315/31 SMC1 drive circuit is malfunctioning for 0.05 sec. or more. Short to +B. · Diagnostic trouble codes
- C1319/35 SCSS drive circuit is malfunctioning for 0.05 sec. or more. Short to +B in SCSS. · Diagnostic trouble codes
- C1341/62 Hydraulic pressure control on FR wheel has deteriorated. · Diagnostic trouble codes
- C1345/66 Value of initialization of linear solenoid valve and calibration for the FR wheel is not stored. · Diagnostic trouble codes
- C1365/54 Sensor power 1 (VCM1) voltage is 4.7 V or less or 5.3 V or more for at least 0.05 sec. · Diagnostic trouble codes
- C1377/43 Brake control power supply assembly is deteriorated (indicates a need to replace). · Diagnostic trouble codes
- C1378/44 Open or short in FAIL line. Malfunction inside the power back up unit. · Diagnostic trouble codes
- C1381/97 Power source voltage is not within specified range when communication between skid control ECU and sensor is... · Diagnostic trouble codes
- C1391/69 Accumulation performance is deteriorated (improper sealing inside the actuator, gas pressure drop inside the... · Diagnostic trouble codes
- U0073/94 When either of the following is detected: After the output of data from the skid control ECU is completed,... · Diagnostic trouble codes
- ABS Warning Light Remains ON · Circuit diagnosis
- ABS Warning Light does not Come ON · Circuit diagnosis
- Brake Warning Light Remains ON · Circuit diagnosis
- Brake Warning Light does not Come ON · Circuit diagnosis
- Brake Control Warning Light Remains ON · Circuit diagnosis
- Brake Control Warning Light does not Come ON · Circuit diagnosis
- Slip Indicator Light Remains ON · Circuit diagnosis
- Slip Indicator Light does not Come ON · Circuit diagnosis
- Skid Control Buzzer Circuit · Circuit diagnosis
- TC and CG Terminal Circuit · Circuit diagnosis
- TS and CG Terminal Circuit · Circuit diagnosis
BRAKE ACTUATOR
- COMPONENTS · Components
- ON-VEHICLE INSPECTION · Inspection
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
- DISPOSAL · Removal / installation
FRONT SPEED SENSOR
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
REAR SPEED SENSOR
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
YAW RATE SENSOR
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
STEERING SENSOR
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
SKID CONTROL ECU
BRAKE CONTROL POWER SUPPLY
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
BRAKE PEDAL STROKE SENSOR
- COMPONENTS · Components
- INSPECTION · Inspection
- REMOVAL · Removal / installation
- INSTALLATION · Removal / installation
ABS MAIN RELAY
ABS MOTOR RELAY
BRAKE SYSTEM
- PRECAUTION · Precautions
- SYSTEM DIAGRAM · System information
- PROBLEM SYMPTOMS TABLE · Troubleshooting
BRAKE FLUID
BRAKE PEDAL
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- ADJUSTMENT · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
BRAKE MASTER CYLINDER
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
FRONT BRAKE
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
- INSPECTION · Removal / installation
FRONT BRAKE FLEXIBLE HOSE
REAR BRAKE
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
- INSPECTION · Removal / installation
REAR BRAKE FLEXIBLE HOSE
PARKING BRAKE
PARKING BRAKE SYSTEM
PARKING BRAKE PEDAL (for LHD)
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation
PARKING BRAKE PEDAL (for RHD)
- COMPONENTS · Components
- REMOVAL · Removal / installation
- DISASSEMBLY · Removal / installation
- REASSEMBLY · Removal / installation
- INSTALLATION · Removal / installation