Carlton 2000, Rekord-E ,, ,1979 cc ,1981-86 ,Engine Code 20S

Ignition data

Carlton 2000, Rekord-E
Ignition system type: El-h
Ignition coil make/type: Lu/DLB102
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.6-0.9 Ohms
Secondary resistance: 6300-9300 Ohms
Distributor make/type: Bo/0 237 020 042
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 2/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 5/800 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: WR7BC
Electrode gap: 0.7 mm

Fuel System

Carlton 2000, Rekord-E
Fuel type: L/U
Fuel pump type/pressure: Mech/0.20 bar
Engine idle speed: 825
25 rpm
Fast idle speed: 2000-2100 rpm
CO level at idle speed: 1.0
0.5 Vol %

Engine Data

Carlton 2000, Rekord-E
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 11-13 bar
Oil pressure: 2/500 bar/eng/rpm
Radiator pressure cap: 1-1.5 bar/type
Drive belt 1 - size: 9.5x900 KDB900 mm/type
Drive belt 2 - size: 9.5x875 KDB875 mm/type

Electrical System

Carlton 2000, Rekord-E
Alternator output: 55/2500 Amps/eng/rpm
Regulated output: 13.7-14.5 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Lu/LRS209

Other data

Carlton 2000, Rekord-E
Clutch operation type: Cable
Clutch adjustment: 155/P.Travel mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)