Carlton 1800, ,, 1796 cc, ,1982-86 ,Engine Code 18S

Ignition data

Carlton 1800,
Ignition system type: El-h
Ignition coil make/type: Lu/DLB102
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.6-0.9 Ohms
Secondary resistance: 6300-9300 Ohms
Distributor make/type: Bo/0 237 021 019
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 7/900 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 10/900 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: WR6DP
Electrode gap: 0.7 mm

Fuel System

Carlton 1800,
Fuel type: L/U
Fuel pump type/pressure: Mech/0.18-0.24 bar
Engine idle speed: 900-850 [AT=800-850] rpm
Fast idle speed: 2000
50 rpm
CO level at idle speed: 1.0-1.5 Vol %

Engine Data

Carlton 1800,
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: n / a bar
Oil pressure: 1.5/900 bar/eng/rpm
Radiator pressure cap: 1.3-1.35 bar/type
Drive belt 1 - size: 9.5x900 KDB900 mm/type
Drive belt 2 - size: 9.5x875 KDB875 mm/type

Electrical System

Carlton 1800,
Alternator output: 45/2500 Amps/eng/rpm
Regulated output: 13.7-14.5 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Lu/LRS209

Other data

Carlton 1800,
Clutch operation type: Cable
Clutch adjustment: 155/P.Travel mm
Cambelt failure: Safe
Cambelt Part Number: 90409900
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)