Hi-Ace(RH20), Hi-Lux(RN25/40) ,, 1587 cc, 1977-86, Engine Code 12R,,

Ignition data

Hi-Ace(RH20), Hi-Lux(RN25/40)
Ignition system type: CB
Ignition coil make/type: Lu/DLJ100
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 1.3-1.5 Ohms
Secondary resistance: 7500-10000 Ohms
Distributor make/type: Den/31021
Contact breaker gap/air: 0.45 mm
Dwell angle: 50-54 Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 8/700 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BPR5EAL
Electrode gap: 0.8 mm

Fuel System

Hi-Ace(RH20), Hi-Lux(RN25/40)
Fuel type: L
Fuel pump type/pressure: Mech/0.2-0.3 bar
Engine idle speed: 700 rpm
Fast idle speed: 3200 rpm
CO level at idle speed: 0.5-2.5 Vol %

Engine Data

Hi-Ace(RH20), Hi-Lux(RN25/40)
Valve clearance - inlet: 0.20 h mm (hot)
Valve clearance - exhaust: 0.36 h mm (hot)
Compression pressure: 9-11 bar
Oil pressure: n / a bar/eng/rpm
Radiator pressure cap: 0.9 bar/type
Drive belt 1 - size: 9.5x838 KDB838 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Hi-Ace(RH20), Hi-Lux(RN25/40)
Alternator output: 40/2500 Amps/eng/rpm
Regulated output: 13.8-14.8 Volts
Battery: 12/60 V/Ah
Starter motor make/type: Den/12v-0.8 kW

Other data

Hi-Ace(RH20), Hi-Lux(RN25/40)
Clutch operation type: Hyd
Clutch adjustment: 5-15/Pedal mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: n / a bar (psi)