Lite-Ace, (KM30/1/6) ,, 1486 cc, 1985-91, Engine Code 5K,

Ignition data

Lite-Ace, (KM30/1/6)
Ignition system type: El-i
Ignition coil make/type: Den/-
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 1.3-1.6 Ohms
Secondary resistance: 7700-10400 Ohms
Distributor make/type: Den/19060-13090
Contact breaker gap/air: 0.2-0.4 mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 5
2/800 + vac Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 5
2/800 + vac Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BPR 5EY
Electrode gap: 0.7-0.8 mm

Fuel System

Lite-Ace, (KM30/1/6)
Fuel type: L/U
Fuel pump type/pressure: Mech/0.2-0.3 bar
Engine idle speed: 800
50 rpm
Fast idle speed: 3600
200 rpm
CO level at idle speed: 1.5
0.5 Vol %

Engine Data

Lite-Ace, (KM30/1/6)
Valve clearance - inlet: 0.20 h mm (hot)
Valve clearance - exhaust: 0.30 h mm (hot)
Compression pressure: 8.8-12.4 bar
Oil pressure: n / a bar/eng/rpm
Radiator pressure cap: 0.74-1.03 bar/type
Drive belt 1 - size: 9.5x875 KDB875 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Lite-Ace, (KM30/1/6)
Alternator output: 50/2000 Amps/eng/rpm
Regulated output: 13.8-14.8 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Lu/LRS609

Other data

Lite-Ace, (KM30/1/6)
Clutch operation type: Cable
Clutch adjustment: 4.5-5.5/Lever mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 3.2(46)f 3.2(46)r bar (psi)