MR2, ,, 1587 cc, 1985-90, Engine Code 4A-GE,

Ignition data

MR2,
Ignition system type: El-i
Ignition coil make/type: Lu/DLJ100
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.5-0.7 [87-=0.52-0.64] Ohms
Secondary resistance: 11000-16000 [87-=11500-15500] Ohms
Distributor make/type: Den/-
Contact breaker gap/air: 0.2-0.4 mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 10/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 10/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/R
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BCPR6EY
Electrode gap: 1.1 mm

Fuel System

MR2,
Fuel type: L/U
Fuel pump type/pressure: Elec/2.0 bar
Engine idle speed: 800
50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0-2.0 Vol %

Engine Data

MR2,
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.20-0.30 c mm (cold)
Compression pressure: 9-12.7 bar
Oil pressure: 2.5-5.0/3000 bar/eng/rpm
Radiator pressure cap: 0.75-1.05 bar/type
Drive belt 1 - size: PV/825 KJB825 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

MR2,
Alternator output: 60/2500 Amps/eng/rpm
Regulated output: 13.5-15.1 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Den/12v-0.8kW

Other data

MR2,
Clutch operation type: Hyd
Clutch adjustment: 5-15/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: 1356816020
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)