Starlet, 1.0GL ,, 999 cc, 1985-89, Engine Code 1E (EC),

Ignition data

Starlet, 1.0GL
Ignition system type: CB
Ignition coil make/type: Den/90919
Supply voltage: 4.5 + Volts with ballast resistor
Primary resistance: 1.4 Ohms
Secondary resistance: 10700-14500 Ohms
Distributor make/type: Den/10020
Contact breaker gap/air: 0.45 mm
Dwell angle: 46-58 Deg
Ignition Timing - unleaded: 5/950 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 5/950 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: RN10Y
Electrode gap: 0.8 mm

Fuel System

Starlet, 1.0GL
Fuel type: L/U
Fuel pump type/pressure: Mech/0.2-0.3 bar
Engine idle speed: 800
50 rpm
Fast idle speed: 4800
200 rpm
CO level at idle speed: 2.0
0.5 Vol %

Engine Data

Starlet, 1.0GL
Valve clearance - inlet: 0.20 h mm (hot)
Valve clearance - exhaust: 0.20 h mm (hot)
Compression pressure: 10-12 bar
Oil pressure: 2.5-5/3000 bar/eng/rpm
Radiator pressure cap: 0.75-1.05 bar/type
Drive belt 1 - size: 9.5x875 KDB875 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Starlet, 1.0GL
Alternator output: 45/2500 Amps/eng/rpm
Regulated output: 13.5-15.1 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Lu/LRS266

Other data

Starlet, 1.0GL
Clutch operation type: Hyd
Clutch adjustment: 20-35/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: 1356810031
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)