Malaga 1.2, ,, 1193 cc, 1985-93, ,Engine Code 021A 1000

Ignition data

Malaga 1.2,
Ignition system type: El-h
Ignition coil make/type: Bo/0 221 600 008
Supply voltage: 10 - Volts without ballast resistor
Primary resistance: 0.75-0.81 Ohms
Secondary resistance: 6400-11100 Ohms
Distributor make/type: Bo/0 237 021 027
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 3/925 +vac Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 5/925 +vac Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: F5DC
Electrode gap: 0.8 mm

Fuel System

Malaga 1.2,
Fuel type: L/U
Fuel pump type/pressure: Mech/0.2-0.3 bar
Engine idle speed: 925 rpm
Fast idle speed: 2500-2800 rpm
CO level at idle speed: 1.5
0.5 [Cat=0.5-0.7] Vol %

Engine Data

Malaga 1.2,
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 11.5-13.0 bar
Oil pressure: 3.5-4/5000 bar/eng/rpm
Radiator pressure cap: 0.98 bar/type
Drive belt 1 - size: 9.5x750 KDB750 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Malaga 1.2,
Alternator output: 55/6000 Amps/eng/rpm
Regulated output: 14.0 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/9 000 334 102

Other data

Malaga 1.2,
Clutch operation type: Cable
Clutch adjustment: 25/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: SE021012012A
Tyre pressures: 1.9(27)f 1.9(27)r bar (psi)