Toledo, 1.8 16V ,, 1781 cc, , 1993-, Engine Code PL,

Ignition data

Toledo, 1.8 16V
Ignition system type: El-ecu
Ignition coil make/type: Bo/0 221 122 349
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.6-0.75 Ohms
Secondary resistance: 2400-3500 Ohms
Distributor make/type: Bo/0 237 521 047
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 6
1/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: F6DTC
Electrode gap: 0.7-0.9 mm

Fuel System

Toledo, 1.8 16V
Fuel type: U Cat
Fuel pump type/pressure: Elec/4.7-5.4 bar
Engine idle speed: 850-950 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.3-1.0 Vol %

Engine Data

Toledo, 1.8 16V
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 7.5-13 bar
Oil pressure: 2.0 Min/2000 bar/eng/rpm
Radiator pressure cap: 1.3-1.5 bar/type
Drive belt 1 - size: 9.5x635 KDB638 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Toledo, 1.8 16V
Alternator output: 90/3000 Amps/eng/rpm
Regulated output: 12.5-14.5 Volts
Battery: 12/52 V/Ah
Starter motor make/type: Bo/0 001 114 006

Other data

Toledo, 1.8 16V
Clutch operation type: Cable
Clutch adjustment: S/Adj. mm
Cambelt failure: Damage
Cambelt Part Number: 056109119A
Tyre pressures: 2.1(30)f 1.8(26)r bar (psi)