Ibiza 1.2i, Malaga 1.2i ,, 1193 cc, 1989-93, Engine Code 021C.1000,

Ignition data

Ibiza 1.2i, Malaga 1.2i
Ignition system type: El-ecu
Ignition coil make/type: Bo/0 221 600 009
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.6-1.0 Ohms
Secondary resistance: 6400-11000 Ohms
Distributor make/type: Bo/0 237 521 006
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 10/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: F5DC
Electrode gap: 0.7-0.8 mm

Fuel System

Ibiza 1.2i, Malaga 1.2i
Fuel type: U Cat
Fuel pump type/pressure: Elec/1.8-2.0 bar
Engine idle speed: 850
50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.3-0.7 Vol %

Engine Data

Ibiza 1.2i, Malaga 1.2i
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 11.5
1 bar
Oil pressure: 3.5-4.0/5000 bar/eng/rpm
Radiator pressure cap: 0.98 bar/type
Drive belt 1 - size: 9.5x750 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Ibiza 1.2i, Malaga 1.2i
Alternator output: 55/3000 Amps/eng/rpm
Regulated output: n / a Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/-

Other data

Ibiza 1.2i, Malaga 1.2i
Clutch operation type: Cable
Clutch adjustment: 25/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: SE021012012A
Tyre pressures: 2.0(28)f 1.9(27)r bar (psi)