Sunny, Estate/Van ,, 1597 cc, 1990-, ,Engine Code GA16DS

Ignition data

Sunny, Estate/Van
Ignition system type: El-i/ecu
Ignition coil make/type: Han/-
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 1.0 Ohms
Secondary resistance: 10000 Ohms
Distributor make/type: Hit/-
Contact breaker gap/air: 0.3-0.5 mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 2
2/750 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 2
2/750 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BKR6E
Electrode gap: 0.8-0.9 mm

Fuel System

Sunny, Estate/Van
Fuel type: L/U +Cat
Fuel pump type/pressure: Mech/0.20-0.34 bar
Engine idle speed: 750
50 rpm
Fast idle speed: 2100
200 rpm
CO level at idle speed: 1.5
0.5 [Cat=1.0
0.5] Vol %

Engine Data

Sunny, Estate/Van
Valve clearance - inlet: 0.21-0.49 h mm (hot)
Valve clearance - exhaust: 0.30-0.58 h mm (hot)
Compression pressure: 11.3-13.2 bar
Oil pressure: 3.4-4.4/3000 bar/eng/rpm
Radiator pressure cap: 0.78-0.98 bar/type
Drive belt 1 - size: PU/830 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Sunny, Estate/Van
Alternator output: 50/2500 Amps/eng/rpm
Regulated output: 14.1-14.7 Volts
Battery: 12/50 V/Ah
Starter motor make/type: Bo/0 001 311 113

Other data

Sunny, Estate/Van
Clutch operation type: Cable
Clutch adjustment: 2.5-3.5/Lever mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 2.0(28)f 2.0(28)r bar (psi)