Colt 1.2, Lancer 1.2 ,, 1198 cc , 1984-86, Engine Code 4G16 ,

Ignition data

Colt 1.2, Lancer 1.2
Ignition system type: El-i
Ignition coil make/type: Mit/-
Supply voltage: 5 + Volts with ballast resistor
Primary resistance: 1.08-1.49 Ohms
Secondary resistance: 11600-15800 Ohms
Distributor make/type: Mit/-
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 6/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 6/850 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BPR5ES
Electrode gap: 0.7-0.8 mm

Fuel System

Colt 1.2, Lancer 1.2
Fuel type: L/U
Fuel pump type/pressure: Mech/0.26-0.36 bar
Engine idle speed: 850
50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0
0.5 Vol %

Engine Data

Colt 1.2, Lancer 1.2
Valve clearance - inlet: 0.15 h mm (hot)
Valve clearance - exhaust: 0.25 h mm (hot)
Compression pressure: n / a bar
Oil pressure: 0.8 min/850 bar/eng/rpm
Radiator pressure cap: 0.65-0.75 bar/type
Drive belt 1 - size: 9.5x875 KDB875 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

Colt 1.2, Lancer 1.2
Alternator output: 50/2000 Amps/eng/rpm
Regulated output: 14.1-15.0 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Lu/LRS515

Other data

Colt 1.2, Lancer 1.2
Clutch operation type: Hyd
Clutch adjustment: 5-10/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: MD116786
Tyre pressures: 1.6(23)f 1.6(23)r bar (psi)