Piazza Turbo, (JR 1200) ,, 1994 cc, 1988-91, , Engine Code 4ZCI-T
Ignition Data
Ignition system type: El-ecu
Ignition coil make/type: E12-111
Supply voltage: 12 - Volts without ballast resistor
Primary resistance: 1.13-1.53 Ohms
Secondary resistance: 10200-13800 Ohms
Distributor make/type: Hit/-
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 12/900+vac Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 12/900+vac Deg eng/rpm (without vacuum)
Timing mark location: Pulley
o 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: RN7YC
Electrode gap: 0.75 mm
Fuel System
Fuel type: L/U
Fuel pump type/pressure: Elec/2.5-2.9 bar
Engine idle speed: 900 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 2.5 0.5 Vol %
Engine Data
Valve clearance - inlet: 0.15 h mm (hot)
Valve clearance - exhaust: 0.25 h mm (hot)
Compression pressure: 9-12 bar
Oil pressure: 4.0/3000 bar/eng/rpm
Radiator pressure cap: 1.05 bar/type
Drive belt 1 - size: 12.5x900 KDB900 mm/type
Drive belt 2 - size: KDB750/KDB950 mm/type
Electrical System
Alternator output: 65/2700 Amps/eng/rpm
Regulated output: 14.05-15.03 Volts
Battery: 12/40 V/Ah
Starter motor make/type: Den/0.9 Kw
Other Data
Clutch operation type: Hyd
Clutch adjustment: 11-17/Pedal mm
Cambelt failure: Damage
Cambelt Part Number: 8970668630
Tyre pressures: 1.9(27)f 1.9(27)r bar (psi)
Back to page top
Trooper, 2.3 ,, 2254 cc, , 1986-88 , Engine Code 4ZDI
Ignition Data
Ignition system type: El-i
Ignition coil make/type: Hit/-
Supply voltage: n / a
Primary resistance: 1.13-1.65 Ohms
Secondary resistance: 10700-14500 Ohms
Distributor make/type: Hit/-
Contact breaker gap/air: 0.2-0.4 mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 6/800+vac Deg eng/rpm (without
vacuum)
Ignition Timing - leaded: 6/800+vac Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BP6ES
Electrode gap: 0.7-0.8 mm
Fuel System
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24 bar
Engine idle speed: 800 50 [AC=900] rpm
Fast idle speed: 2700-3000 rpm
CO level at idle speed: 2.5 0.5 Vol %
Engine Data
Valve clearance - inlet: 0.2 h mm (hot)
Valve clearance - exhaust: 0.3 h mm (hot)
Compression pressure: 8.5-12 bar
Oil pressure: 4.0/3000 bar/eng/rpm
Radiator pressure cap: 0.9-1.2 bar/type
Drive belt 1 - size: 12.5x1025 KDB102 mm/type
Drive belt 2 - size: KDB775 mm/type
Electrical System
Alternator output: 30/1900 Amps/eng/rpm
Regulated output: 14.2-14.8 Volts
Battery: 12/ 60 V/Ah
Starter motor make/type: Den/1.0 kW
Other Data
Clutch operation type: Cable
Clutch adjustment: 5/Lever mm
Cambelt failure: Damage
Cambelt Part Number: 8970417840
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)
Back to page top
Trooper, 2.6i ,, 2559 cc, 1988-92 Engine Code 4ZE1
Ignition Data Ignition system type: El-ecu Ignition coil make/type: n / a Supply voltage: n / a Primary resistance: 0.9 Ohms Secondary resistance: n / a Ohms Distributor make/type: n / a Contact breaker gap/air: 0.2-0.4 mm Dwell angle: n / a Deg Ignition Timing - unleaded: 12/900 +vac Deg eng/rpm (without vacuum) Ignition Timing - leaded: 12/900 +vac Deg eng/rpm (without vacuum) Timing mark location: Pulley No 1 plug location: Pulley Firing Order: 1-3-4-2 Spark plug make: NGK Spark plug type: BPR6ES-11 Electrode gap: 1.0-1.1 mm Fuel System Fuel type: L/U Fuel pump type/pressure: Elec/2.5-3.0 bar Engine idle speed: 900 50 rpm Fast idle speed: n / a rpm CO level at idle speed: 1.5 0.5 Vol % Engine Data Valve clearance - inlet: 0.20 h mm (hot) Valve clearance - exhaust: 0.20 h mm (hot) Compression pressure: 11.7 bar Oil pressure: 4.0-5.0/4000 bar/eng/rpm Radiator pressure cap: 1.0 bar/type Drive belt 1 - size: n / a mm/type Drive belt 2 - size: n / a mm/type Electrical System Alternator output: 55/12 Amps/eng/rpm Regulated output: 14.2-14.8 Volts Battery: 12/65 V/Ah Starter motor make/type: Bo/0001 107 009 Other Data Clutch operation type: Cable Clutch adjustment: 5/Lever mm Cambelt failure: Damage Cambelt Part Number: 8970422680 Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)
Back to page top
Trooper 3.2i, V6 24V ,, 3165 cc , 1992- , Engine Code 6VD1
Ignition Data Ignition system type: DI Ignition coil make/type: n / a Supply voltage: n / a Primary resistance: n / a Ohms Secondary resistance: n / a Ohms Distributor make/type: n / a Contact breaker gap/air: n / a mm Dwell angle: n / a Deg Ignition Timing - unleaded: 16/750 Deg eng/rpm (without vacuum) Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum) Timing mark location: n / a No 1 plug location: O/S/F Firing Order: 1-2-3-4-5-6 Spark plug make: NGK Spark plug type: BKR6E-11 Electrode gap: 1.05 mm Fuel System Fuel type: U Cat Fuel pump type/pressure: Elec/- bar Engine idle speed: 750 rpm Fast idle speed: n / a rpm CO level at idle speed: 0.5 Max Vol % Engine Data Valve clearance - inlet: Hyd Valve clearance - exhaust: Hyd Compression pressure: 12.0 bar Oil pressure: 0.5/750 bar/eng/rpm Radiator pressure cap: 0.88-1.18 bar/type Drive belt 1 - size: n / a mm/type Drive belt 2 - size: n / a mm/type Electrical System Alternator output: 60/2000 Amps/eng/rpm Regulated output: n / a Volts Battery: 12/90 V/Ah Starter motor make/type: Hit/GD002350 Other Data Clutch operation type: Hyd Clutch adjustment: 5-15/Pedal mm Cambelt failure: Damage Cambelt Part Number: 8970163260 Tyre pressures: 2.1(30)f 2.4(35)r bar (psi)
Back to page top