Capri, 2.0,, 1993 cc, 1980-87, Engine Code NNE,
Ignition data
Capri, 2.0
Ignition system type: CB
Ignition coil make/type: Lu/DLB120
Supply voltage: n / a
Primary resistance: 0.95-1.60 Ohms
Secondary resistance: n / a Ohms
Distributor make/type: Mot/76HF-DA
Contact breaker gap/air: 0.6 mm
Dwell angle: 48-52 Deg
Ignition Timing - unleaded: 4/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 8/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Motorcraft
Spark plug type: BRF 22
Electrode gap: 0.75 mm
Fuel System
Capri, 2.0
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24-0.36 bar
Engine idle speed: 800 25 rpm
Fast idle speed: 2000 100 rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
Capri, 2.0
Valve clearance - inlet: 0.20 c mm (cold)
Valve clearance - exhaust: 0.25 c mm (cold)
Compression pressure: 10-12 bar
Oil pressure: 2.5/1500 bar/eng/rpm
Radiator pressure cap: 0.9 bar/type
Drive belt 1 - size: 9.5x864 KDB865 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
Capri, 2.0
Alternator output: 35/6000 Amps/eng/rpm
Regulated output: 14.2-14.6 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Lu/LRS110
Other data
Capri, 2.0
Clutch operation type: Cable
Clutch adjustment: 145/P.Travel mm
Cambelt failure: Safe
Cambelt Part Number: 6139911
Tyre pressures: 1.5(21)f 1.9(27)r bar (psi)
Capri, 2.8i,, 2792 cc, 1981-87, , Engine Code PRN ,
Ignition data
Capri, 2.8i
Ignition system type: El-i
Ignition coil make/type: Lu/DLB120
Supply voltage: n / a
Primary resistance: 0.75-0.85 Ohms
Secondary resistance: 5000-6000 Ohms
Distributor make/type: Bo/0 237 306 007
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 9/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 12/900 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-4-2-5-3-6
Spark plug make: Motorcraft
Spark plug type: AGR 22C
Electrode gap: 0.6 mm
Fuel System
Capri, 2.8i
Fuel type: L/U
Fuel pump type/pressure: Elec/5.5 0.25 bar
Engine idle speed: 900 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.2 [-1983=1.25 0.25] Vol
%
Engine Data
Capri, 2.8i
Valve clearance - inlet: 0.35 c mm (cold)
Valve clearance - exhaust: 0.40 c mm (cold)
Compression pressure: 11.5-12.5 bar
Oil pressure: 2.5/2000 bar/eng/rpm
Radiator pressure cap: 0.85-1.10 bar/type
Drive belt 1 - size: 11.9x980 KDB975 mm/type
Drive belt 2 - size: 12.5x1270 KEB127 mm/type
Electrical System
Capri, 2.8i
Alternator output: 70/3000 Amps/eng/rpm
Regulated output: 13.7-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/0 001 311 101
Other data
Capri, 2.8i
Clutch operation type: Cable
Clutch adjustment: 150/P.Travel mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 1.9(27)f 1.9(27)r bar (psi)
Maverick, 2.4,, 2389 cc, 1993-, Engine Code KA24E,
Ignition data
Maverick, 2.4
Ignition system type: El-ecu
Ignition coil make/type: n / a
Supply voltage: n / a
Primary resistance: n / a Ohms
Secondary resistance: n / a Ohms
Distributor make/type: n / a
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 10 2/800 Deg eng/rpm (without
vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: N9K
Spark plug type: ZFR5E-11
Electrode gap: 1.0-1.1 mm
Fuel System
Maverick, 2.4
Fuel type: U Cat
Fuel pump type/pressure: Elec/2.2-2.9 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 max Vol %
Engine Data
Maverick, 2.4
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 9.8-13.2 bar
Oil pressure: 4.1-4.8/3000 bar/eng/rpm
Radiator pressure cap: 0.78-1.0 bar/type
Drive belt 1 - size: n / a mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
Maverick, 2.4
Alternator output: 65/5000 Amps/eng/rpm
Regulated output: 14.1-14.7 Volts
Battery: 12/60 V/Ah
Starter motor make/type: Hit/S114-703A
Other data
Maverick, 2.4
Clutch operation type: Hyd
Clutch adjustment: 145/P. Travel mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 1.8(26)f 2.2(32)r [5 Door=1.9(28)f 2.5(37)r] bar
(psi)
P100, 1.6,, 1598 cc, 1982-88, , Engine Code LCR,
Ignition data
P100, 1.6
Ignition system type: CB
Ignition coil make/type: Lu/DLB120
Supply voltage: 4.53+ Volts with ballast resistor
Primary resistance: 1.0-1.4 Ohms
Secondary resistance: n / a Ohms
Distributor make/type: Mot/TRA/NA
Contact breaker gap/air: 0.45 mm
Dwell angle: 48-52 Deg
Ignition Timing - unleaded: 2/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 6/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Motorcraft
Spark plug type: BF 22
Electrode gap: 0.65 mm
Fuel System
P100, 1.6
Fuel type: L/U
Fuel pump type/pressure: Mech/0.28-0.36 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
P100, 1.6
Valve clearance - inlet: 0.20 c mm (cold)
Valve clearance - exhaust: 0.25 c mm (cold)
Compression pressure: 11-13 bar
Oil pressure: 1-1.25/1500 bar/eng/rpm
Radiator pressure cap: 0.9 bar/type
Drive belt 1 - size: 9.5x865 KDB865 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
P100, 1.6
Alternator output: 35/6000 Amps/eng/rpm
Regulated output: 13.7-14.5 Volts
Battery: 12/60 V/Ah
Starter motor make/type: Bo/0 001 311 113
Other data
P100, 1.6
Clutch operation type: Cable
Clutch adjustment: 150/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 6139910
Tyre pressures: 2.5(36)f 2.5(36)r bar (psi)
P100, 2.0,, 1993 cc, 1988-, , Engine Code NAE,
Ignition data
P100, 2.0
Ignition system type: El-i
Ignition coil make/type: Mot/-
Supply voltage: n / a
Primary resistance: 0.72-0.88 Ohms
Secondary resistance: 4500-7000 Ohms
Distributor make/type: Mot/86HF12100
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 2/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 6/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: Pulley
Firing Order: 1-3-4-2
Spark plug make: Motorcraft
Spark plug type: BRF 32C
Electrode gap: 0.75 mm
Fuel System
P100, 2.0
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24-0.38 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0 0.5 Vol %
Engine Data
P100, 2.0
Valve clearance - inlet: 0.20 0.03 c mm (cold)
Valve clearance - exhaust: 0.25 0.03 c mm (cold)
Compression pressure: 10-12 bar
Oil pressure: 2.5/2000 bar/eng/rpm
Radiator pressure cap: 1.2-1.5 bar/type
Drive belt 1 - size: 9.5x913 KDB913 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
P100, 2.0
Alternator output: 55/6000 Amps/eng/rpm
Regulated output: 13.7-14.6 Volts
Battery: n / a V/Ah
Starter motor make/type: Bo/EF
Other data
P100, 2.0
Clutch operation type: Cable
Clutch adjustment: S/Adj. mm
Cambelt failure: Safe
Cambelt Part Number: 6139911
Tyre pressures: 1.8(26)f 2.5(36)r bar (psi)