Fiesta
84/87, 1.1, 1117 cc, 1983-89, Engine Code GSF
Ignition data
Ignition system type: CB
Ignition coil make/type: Lu/DLB120
Supply voltage: 7.0 + Volts with ballast resistor
Primary resistance: 1.2-1.4 Ohms
Secondary resistance: 4500-7000 Ohms
Distributor make/type: Bo/0 231 170 328
Contact breaker gap/air: 0.45 mm
Dwell angle: 48-52 Deg
Ignition Timing - unleaded: 2/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 6/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-2-4-3
Spark plug make: Motorcraft
Spark plug type: AGRF22 [1.86-=AGRF22C]
Electrode gap: 0.75 mm
Fuel System
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24-0.38 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
Valve clearance - inlet: 0.22 c mm
(cold)
Valve clearance - exhaust: 0.59 c mm (cold)
Compression pressure: 13-15 bar
Oil pressure: 0.6/750 bar/eng/rpm
Radiator pressure cap: 0.91-1.02 bar/type
Drive belt 1 - size: 9.5x825 KDB825 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
Alternator output: 45/6000
Amps/eng/rpm
Regulated output: 13.7-14.6 Volts
Battery: 12/50 V/Ah
Starter motor make/type: Bo/0 001 208 223
Other data
Clutch operation type: Cable
Clutch adjustment: S/Adj. mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)
Fiesta
87, 1.1, 1117 cc, 1987-89, Engine Code GS/GL
Ignition data
Ignition system type: El-i
Ignition coil make/type: Bo/0 221 122 367
Supply voltage: n / a
Primary resistance: 1.13-1.33 Ohms
Secondary resistance: 3500-6500 Ohms
Distributor make/type: Bo/0 237 601 008
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 2/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 6/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-2-4-3
Spark plug make: Motorcraft
Spark plug type: AGRF22C
Electrode gap: 0.75 mm
Fuel System
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24-0.38 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
Valve clearance - inlet: 0.22 c mm (cold)
Valve clearance - exhaust: 0.59 c mm (cold)
Compression pressure: 13.3-15.3 bar
Oil pressure: 1.5/2000 bar/eng/rpm
Radiator pressure cap: 0.91 bar/type
Drive belt 1 - size: 9.5x825 KDB825 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
Alternator output: 55/2000
Amps/eng/rpm
Regulated output: 13.7-14.6 Volts
Battery: 12/50 V/Ah
Starter motor make/type: Bo/0 001 211 246
Other data
Clutch operation type: Cable
Clutch adjustment: S/Adj. mm
Cambelt failure: n / a
Cambelt Part Number: n / a
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)
Fiesta
84, 1.3, 1296 cc, 1984-86, Engine Code JPC
Ignition data
Ignition system type: El-i
Ignition coil make/type: Lu/DLB120
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.68-0.91 Ohms
Secondary resistance: 4500-7000 Ohms
Distributor make/type: Bo/0 237 521 003
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 8/800 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 12/800 Deg eng/rpm (without vacuum)
Timing mark location: Pulley
No 1 plug location: O/S/F
Firing Order: 1-3-4-2
Spark plug make: Motorcraft
Spark plug type: AGPR22CD
Electrode gap: 0.75 mm
Fuel System
Fuel type: L/U
Fuel pump type/pressure: Mech/0.24-0.38 bar
Engine idle speed: 800 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: 11.2-14.8 bar
Oil pressure: 2.8/2000 bar/eng/rpm
Radiator pressure cap: 0.91-1.02 bar/type
Drive belt 1 - size: 9.5x813 KDB813 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
Alternator output: 45/6000
Amps/eng/rpm
Regulated output: 13.7-14.6 Volts
Battery: 12/50 V/Ah
Starter motor make/type: Bo/0 001 208 223
Other data
Clutch operation type: Cable
Clutch adjustment: S/Adj. mm
Cambelt failure: Damage
Cambelt Part Number: 1660554 [New tensioner req.]
Tyre pressures: 1.8(26)f 1.8(26)r bar (psi)