BX 16,, 1580 cc, 1991-92, Engine Code XU5M3/L (BDY)
Ignition data
BX 16,
Ignition system type: DIS
Ignition coil make/type: Bo/Val/BAE04
Supply voltage: 12 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 14600/8600 Ohms
Distributor make/type: n / a
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: F7DCOR
Electrode gap: 0.9 mm
Fuel System
BX 16,
Fuel type: U
Fuel pump type/pressure: Elec/0.8 bar
Engine idle speed: 850 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 Max Vol %
Engine Data
BX 16,
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB950 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 16,
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/0 001 112 019
Other data
BX 16,
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722 [114 teeth=96141369]
Tyre pressures: 1.9(27)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX 19GT/Digit, BX 19 TRS,1905 cc, 1982-87, Engine Code 159A
Ignition data
BX 19GT/Digit, BX 19 TRS
Ignition system type: El-i
Ignition coil make/type: Duc/520015A
Supply voltage: 10 - Volts without ballast resistor
Primary resistance: 0.82 Ohms
Secondary resistance: 5700-6300 Ohms
Distributor make/type: Duc/525692
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 8/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 11/700 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: S7YC
Electrode gap: 0.6 mm
Fuel System
BX 19GT/Digit, BX 19 TRS
Fuel type: L/U
Fuel pump type/pressure: Mech/- bar
Engine idle speed: 675 25 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0-2.1 Vol %
Engine Data
BX 19GT/Digit, BX 19 TRS
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB963 mm/type
Drive belt 2 - size: 9.5x775 KDB775 mm/type
Electrical System
BX 19GT/Digit, BX 19 TRS
Alternator output: 47/1800 Amps/eng/rpm
Regulated output: 13.8-14.4 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Lu/LRS459
Other data
BX 19GT/Digit, BX 19 TRS
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722 [114 teeth=96141369]
Tyre pressures: 2.0(28)f 2.3(31)r bar (psi)
Back to page top or return to menu
BX 19 TRS,, 1905 cc, 1986-90, Engine Code D2A (XU92C)
Ignition data
BX 19 TRS,
Ignition system type: El-i
Ignition coil make/type: Duc/520015A
Supply voltage: 10 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 5700-6300 Ohms
Distributor make/type: Duc/C001/D001
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 7/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 10/850 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: 9YCX
Electrode gap: 0.8 mm
Fuel System
BX 19 TRS,
Fuel type: L/U
Fuel pump type/pressure: Mech/- bar
Engine idle speed: 650-750 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
BX 19 TRS,
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/963 KIB963 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 19 TRS,
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: P R/D8E154
Other data
BX 19 TRS,
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722
Tyre pressures: 1.9(27)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX 19, 4x4, 1905 cc, 1989-90, Engine Code D2E (XU92C+)
Ignition data
BX 19, 4x4
Ignition system type: El-i
Ignition coil make/type: Duc/520015A
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 5700-6300 Ohms
Distributor make/type: Duc/C001/D001
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 7/850 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 10/850 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: C9YCX
Electrode gap: 0.8 mm
Fuel System
BX 19, 4x4
Fuel type: L/U
Fuel pump type/pressure: Mech/- bar
Engine idle speed: 650-750 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5 0.5 Vol %
Engine Data
BX 19, 4x4
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/963 KIB963 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 19, 4x4
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: P R/D8E154
Other data
BX 19, 4x4
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722
Tyre pressures: 2.1(30)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX 19i, +4x4, 1905 cc, 1988-92, Engine Code DDZ (XU9M)
Ignition data
BX 19i, +4x4
Ignition system type: El-ecu
Ignition coil make/type: Sol/72396.002
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: n / a Ohms
Secondary resistance: n / a Ohms
Distributor make/type: Sol/18 280
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Eyquem
Spark plug type: C62LJS
Electrode gap: 0.6-0.7 mm
Fuel System
BX 19i, +4x4
Fuel type: U Cat
Fuel pump type/pressure: Elec/0.7-0.9 bar
Engine idle speed: 850 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 Max Vol %
Engine Data
BX 19i, +4x4
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB950 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 19i, +4x4
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: P R/D8E154
Other data
BX 19i, +4x4
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722 [114 teeth=96141369]
Tyre pressures: 2.1(30)f 2.1(30)r bar (psi)
Back to page top or return to menu