ZX, 1.1, 1124 cc, 1991-, Engine Code HIA(TU1K)
Ignition data
ZX, 1.1
Ignition system type: El-i
Ignition coil make/type: Valeo/BTR05
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 6500 Ohms
Distributor make/type: Du/C041/D029
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 8/750 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 8/750 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: C9YCX
Electrode gap: 0.8 mm
Fuel System
ZX, 1.1
Fuel type: L/U
Fuel pump type/pressure: Mech/0.28 bar
Engine idle speed: 850-900 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.8-1.2 Vol %
Engine Data
ZX, 1.1
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 4.0/4000 bar/eng/rpm
Radiator pressure cap: 1.4 bar/type
Drive belt 1 - size: 10x710 KDB710 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
ZX, 1.1
Alternator output: 47/4000 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/- V/Ah
Starter motor make/type: Valeo/D6RA37
Other data
ZX, 1.1
Clutch operation type: Cable
Clutch adjustment: 140/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: n / a
Tyre pressures: 2.2(31)f 2.2(31)r bar (psi)
Back to page top or return to menu
ZX, 1.1i, 1124 cc, 1991-, Engine Code HDZ(TU1M2)
Ignition data
ZX, 1.1i
Ignition system type: El-i
Ignition coil make/type: n / a
Supply voltage: n / a
Primary resistance: n / a Ohms
Secondary resistance: n / a Ohms
Distributor make/type: n / a
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: C9YCX
Electrode gap: 0.8 mm
Fuel System
ZX, 1.1i
Fuel type: U Cat
Fuel pump type/pressure: Elec/1.0-1.2 bar
Engine idle speed: 850-900 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 Max Vol %
Engine Data
ZX, 1.1i
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 4.0/4000 bar/eng/rpm
Radiator pressure cap: 1.4 bar/type
Drive belt 1 - size: 10x710 KDB710 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
ZX, 1.1i
Alternator output: 47/4000 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Valeo/D6RA37
Other data
ZX, 1.1i
Clutch operation type: Cable
Clutch adjustment: 140/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: n / a
Tyre pressures: 2.2(31)f 2.2(31)r bar (psi)
Back to page top or return to menu
ZX, 1.4, ,1360 cc, 1991-,Engine Code K2D(TU32K) [Cat=TU3MZ]
Ignition data
ZX, 1.4
Ignition system type: El-i
Ignition coil make/type: Du/2 526 275
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 6500 Ohms
Distributor make/type: Du/2 525 275
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 8 2/850 Deg eng/rpm (without
vacuum)
Ignition Timing - leaded: 8/750 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BCPR6ES
Electrode gap: 0.8 mm
Fuel System
ZX, 1.4
Fuel type: U+Cat
Fuel pump type/pressure: Cat=Elec/1.0-1.2 bar
Engine idle speed: 850-900 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.8-1.2 [Cat=0.5 Max] Vol %
Engine Data
ZX, 1.4
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 4.0/4000 bar/eng/rpm
Radiator pressure cap: 1.4 bar/type
Drive belt 1 - size: 10x710 KDB710 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
ZX, 1.4
Alternator output: 47/4000 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Valeo/D6RA37
Other data
ZX, 1.4
Clutch operation type: Cable
Clutch adjustment: 140/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 96097062
Tyre pressures: 2.2(31)f 2.2(31)r bar (psi)
Back to page top or return to menu
ZX, 1.6i, 1580 cc, 1991-, Engine Code B4A(XU5M2K) [Cat=XU5M3Z]
Ignition data
ZX, 1.6i
Ignition system type: DIS
Ignition coil make/type: n / a
Supply voltage: n / a
Primary resistance: n / a Ohms
Secondary resistance: n / a Ohms
Distributor make/type: n / a
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: NGK
Spark plug type: BCPR6ES
Electrode gap: 0.8 mm
Fuel System
ZX, 1.6i
Fuel type: U+Cat
Fuel pump type/pressure: Elec/0.7-0.9 bar
Engine idle speed: 850-900 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0 Cat=0.5 Vol %
Engine Data
ZX, 1.6i
Valve clearance - inlet: 0.20 c mm (cold)
Valve clearance - exhaust: 0.40 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 4.5/4000 bar/eng/rpm
Radiator pressure cap: 1.4 bar/type
Drive belt 1 - size: PV/700 KIB700 mm/type
Drive belt 2 - size: PV/963 KIB963 mm/type
Electrical System
ZX, 1.6i
Alternator output: 47/4000 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/44 V/Ah
Starter motor make/type: Valeo/D6RA37
Other data
ZX, 1.6i
Clutch operation type: Cable
Clutch adjustment: 140/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722 [114 teeth=9614169]
Tyre pressures: 2.2(31)f 2.2(31)r bar (psi)
Back to page top or return to menu