BX 19GTi, BX 19 TRi Est., 1905 cc, 1986-90, Engine Code D6A(XU9J2)
Ignition data
BX 19GTi, BX 19 TRi Est.
Ignition system type: El-i
Ignition coil make/type: Du/520015A
Supply voltage: 10 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 5700-6300 Ohms
Distributor make/type: Bo/0 237 009 064
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 2/900 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 5/900 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: C7YCX
Electrode gap: 0.8 mm
Fuel System
BX 19GTi, BX 19 TRi Est.
Fuel type: L/U
Fuel pump type/pressure: Elec/2.5 bar
Engine idle speed: 800-850 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.5-2.5 Vol %
Engine Data
BX 19GTi, BX 19 TRi Est.
Valve clearance - inlet: 0.10-0.15 c mm (cold)
Valve clearance - exhaust: 0.20-0.30 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB963 mm/type
Drive belt 2 - size: 9.5x775 KDB775 mm/type
Electrical System
BX 19GTi, BX 19 TRi Est.
Alternator output: 47/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/0 001 208 516
Other data
BX 19GTi, BX 19 TRi Est.
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722
Tyre pressures: 2.0(28)f 2.2(31)r bar (psi)
Back to page top or return to menu
BX19 GTi, BX19 TZi, 1905 cc, 1990-92, Engine Code D6D (XU9J2)
Ignition data
BX19 GTi, BX19 TZi
Ignition system type: DIS
Ignition coil make/type: Val/BAE 04
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 8600 Ohms
Distributor make/type: Bo/0 261 200 026
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Bosch
Spark plug type: F6DCOR
Electrode gap: 0.8 mm
Fuel System
BX19 GTi, BX19 TZi
Fuel type: L/U
Fuel pump type/pressure: Elec/2.8-3.2 bar
Engine idle speed: 850-900 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 1.0-2.0 Vol %
Engine Data
BX19 GTi, BX19 TZi
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB950 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX19 GTi, BX19 TZi
Alternator output: 47/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Duc/534048
Other data
BX19 GTi, BX19 TZi
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91517722 [114 teeth=96141369]
Tyre pressures: 2.1(30)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX 19i,, 1905 cc, 1990-92, Engine Code DKZ (XU9JA/L)
Ignition data
BX 19i,
Ignition system type: El-ecu
Ignition coil make/type: Bo/0 221 122 317
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.8 Ohms
Secondary resistance: 7200 Ohms
Distributor make/type: Bo/-
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Eyquem
Spark plug type: RFC58LS
Electrode gap: 0.8 mm
Fuel System
BX 19i,
Fuel type: U Cat
Fuel pump type/pressure: Elec/2.8-3.2 bar
Engine idle speed: 900 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 Max Vol %
Engine Data
BX 19i,
Valve clearance - inlet: 0.15-0.25 c mm (cold)
Valve clearance - exhaust: 0.35-0.45 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB950 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 19i,
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Duc/534048
Other data
BX 19i,
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91541318 [114 teeth=96141369]
Tyre pressures: 2.1(30)f 2.2(32)r bar (psi)
Back to page top or return to menu
BX 19 TGS, TRS/TZS, 1905 cc, 1991-92, Engine Code D2F (XU92C+)
Ignition data
BX 19 TGS, TRS/TZS
Ignition system type: El-i
Ignition coil make/type: Duc/520 015 A
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.82 Ohms
Secondary resistance: 5700-6300 Ohms
Distributor make/type: Bo/C 062/D 017
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: 10/700 Deg eng/rpm (without vacuum)
Ignition Timing - leaded: 10/700 Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Champion
Spark plug type: C7YCX
Electrode gap: 0.8 mm
Fuel System
BX 19 TGS, TRS/TZS
Fuel type: L/U
Fuel pump type/pressure: Mech/0.32 bar
Engine idle speed: 750 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.8-1.2 Vol %
Engine Data
BX 19 TGS, TRS/TZS
Valve clearance - inlet: 0.15-0.20 c mm (cold)
Valve clearance - exhaust: 0.35-0.40 c mm (cold)
Compression pressure: n / a bar
Oil pressure: 3.5/4000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB700 mm/type
Drive belt 2 - size: PV/KIB950 mm/type
Electrical System
BX 19 TGS, TRS/TZS
Alternator output: 55/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Duc/534048
Other data
BX 19 TGS, TRS/TZS
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91541318
Tyre pressures: 2.2(32)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX GTi, 16V, 1905 cc, 1987-92.,Engine Code D6C (XU9JU),
Ignition data
BX GTi, 16V
Ignition system type: El-ecu
Ignition coil make/type: n / a
Supply voltage: n / a
Primary resistance: n / a Ohms
Secondary resistance: n / a Ohms
Distributor make/type: Bo/0 261 200 119
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Eyquem
Spark plug type: FC62LSZ
Electrode gap: 0.8 mm
Fuel System
BX GTi, 16V
Fuel type: L
Fuel pump type/pressure: Elec/3.0-3.5 bar
Engine idle speed: 850 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.8-1.5 Vol %
Engine Data
BX GTi, 16V
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: n / a bar
Oil pressure: 4.8/3000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB725 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX GTi, 16V
Alternator output: 47/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: LU/LRS 459
Other data
BX GTi, 16V
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91541318
Tyre pressures: 2.2(32)f 2.1(30)r bar (psi)
Back to page top or return to menu
BX 19, 16V, 1905 cc, 1986-92, Engine Code DFW (XU9J4)
Ignition data
BX 19, 16V
Ignition system type: El-ecu
Ignition coil make/type: Duc/256009A
Supply voltage: 11 - Volts without ballast resistor
Primary resistance: 0.7 Ohms
Secondary resistance: 6600 Ohms
Distributor make/type: Bo/0 261 200 158
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: Eyquem
Spark plug type: FC62LS3
Electrode gap: 0.8 mm
Fuel System
BX 19, 16V
Fuel type: U Cat
Fuel pump type/pressure: Elec/2.8-3.2 bar
Engine idle speed: 890 50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5 Max Vol %
Engine Data
BX 19, 16V
Valve clearance - inlet: Hyd
Valve clearance - exhaust: Hyd
Compression pressure: n / a bar
Oil pressure: 4.8/3000 bar/eng/rpm
Radiator pressure cap: 1.0 bar/type
Drive belt 1 - size: PV/KIB950 mm/type
Drive belt 2 - size: n / a mm/type
Electrical System
BX 19, 16V
Alternator output: 47/1800 Amps/eng/rpm
Regulated output: 13.8-14.5 Volts
Battery: 12/45 V/Ah
Starter motor make/type: Bo/0 001 208 228
Other data
BX 19, 16V
Clutch operation type: Cable
Clutch adjustment: 130/P.Travel mm
Cambelt failure: Damage
Cambelt Part Number: 91541318
Tyre pressures: 2.1(30)f 2.0(28)r bar (psi)
Back to page top or return to menu